压力气瓶安全培训.pptxVIP

Compressed Gas CylindersSafety Awareness压缩气瓶安全培训 ; Where compressed gases are to be transported, stored or used shall be recognized to have potential hazards in the risk assessment and appropriate controls shall be identified and implemented 当运输,储存,使用压缩气瓶时, 应认识到所存在的潜在风险,并需要辨识其危险,实施相应的控制措施. Care should be taken if compressed air is to be used to clear surfaces, goggles shall be worn to prevent particles entering the eyes 如果使用压缩空气进行吹扫清理,则应特别小心,并佩戴保护眼镜防止外来颗粒物进入眼内.;The color coding, the name of the gas contained within the cylinder shall be clearly stenciled on the cylinder body 安全季度色标及瓶装气体名称应清楚地印制在气瓶上 Cylinders shall be supplied with protective guards or caps for the valve assemblies. 气瓶应配置保护栏和阀门保护罩 Cylinders shall not be rolled from vehicles and allowed to free-fall onto rubber tires or similar packaging, but shall be lowered to the ground manually or using appropriate lifting equipment 不允许气瓶在车上滚动 摇摆, 不得自由下落到橡胶轮胎或类似的材料上,应手动落地或使用适当的吊装设备落地. ; Inspect rubber hoses to see that they are free from cuts, cracks, burns, and worn places, and arrange them so as they cannot be cut by contact with sharp edges or corners, falling metal, sparks, or blowpipe flame检查橡胶管是否有割伤,划伤,烧伤和破损的地方, 使其避免接触锋利和锋角以及避免跌落金属件,火花或喷管火焰的损伤. Use red hose for acetylene and other combustible gases, and be careful to see that they are never interchanged with other colors 对乙炔和其他可燃气体使用红色的软管,特别注意检查不得与其他颜色的混用.;Use hoses of equal length and do not coil any surplus hose around regulators or cylinders. Oxy-acetylene hoses shall be taped together to keep them tidy 使用相等长度的软管,不要将多余的软钢盘绕在调整阀或气瓶上,氧-乙炔软管应捆扎在一起并保持清洁. Do not use odd bits of tubing. Copper or high copper content alloy shall not be used in acetylene hose or other parts in contact with Acetylene 不可使用零碎的管子.铜或高铜含量的合金管夹不可用于乙炔软管或与乙炔接触的部件上. Never attempt to light a blowpipe until sufficient time has elapsed after opening the blowpipe valve for the gas in the hose to normalize at the correct working pressure and all air to be blown from the hose 不要试图点燃喷火嘴,阀门打开后,