启动汽锅说明书.doc

源牌启动锅炉说明书 ENVIRONMENT? Start-up Boiler Manual 杭州华电华源环境工程有限公司 Hangzhou Huadian Huayuan Environment Engineering Co., Ltd 杭州华源前线能源设备有限公司 Hangzhou Huayuan QianXian Energy Equipments Co., Ltd 地址：杭州市余杭区塘栖镇工业园区（莫家桥） 邮编：311106 Add: Tangxi Industrial Park (Mo Jiaqiao), Yu Hang District, Hangzhou 311106 电话：0571 传真：0571Tel: 0571 Fax: 0571前 言 Foreword 非常感谢您购买我司制造销售的SZS型燃油（气）启动锅炉。本产品是我公司研制开发的新一代环保型、节能型产品。它具有热效率高、操作简便等优点。但如果安装、使用、维护不当，不但不能充分发挥该产品的优良性能，反而可能出现危险。 Thank you very much for purchasing our oil/gas-fired steam boiler, the new generation environment-friendly and energy efficient product we has developed, which is characterized by high thermal efficiency and easy operation. However, in the event that the boiler is not properly installed and used, danger may even occur, not to mention the normal performance it is due to have. 因此，在安装、使用该产品前请认真阅读本说明书、配套的燃烧器等辅机说明书！ Therefore, prior to installation and use of this product, this manual and the instructions of auxiliary units like the burner must be observed. 目 录 Contents Ⅰ、设计说明 4 I. Description of Design 一、锅炉规范 4 i. Specifications for Boiler 二、结构简介 5 ii. Brief Introduction to Structure 三、锅炉运行参数 7 iii. Boiler Operational Parameters Ⅱ、安 装 说 明 7 II. Instructions for Installation 一、安装前准备 8 i. Pre-installation Preparations 二、本体安装 8 ii. Boiler Body Installation 三、烘炉（暖炉） 9 iii. Furnace Drying (Furnace Heating) 四、煮炉 10 iv. Boiling-out 五、总体验收 12 v. Overall Acceptance Ⅲ、锅炉运行操作 13 III. Boiler Running Operating 一、基本要求 13 i. Basic Requirements 二、停炉保养 14 ii. Furnace Blow-out Maintenance Ⅳ、电控操作说明 16 IV. Operating Instructions for Electric Controls 一、开机例行检查 16 i. Routine Inspections during Boiler Start-up 二、启停顺序及控制流程 16 ii. Start-stop Sequence Control Procedure 三、联锁保护及故障处理 19 iii. Interlocking Protection Troubleshooting 四、触摸屏（或上位机）操作 19 iv. Operation on Touch Screen (or Host Computer) Ⅰ、设计说明 I. Description of Design为了缩短电厂建设周期，确保安装进度，我司引进国外先进技术，开发了第二代快装式（整装式）启动锅炉。