造纸Pressfeltscleaning-Chemicalcleaning.中文版.pptVIP

Chemical Conditioning Determine contaminants present.測定現在的汙染物 Proper selection of chemical cleaning agents depends upon a number of variables.依據一些變化參數來選擇適當的化學藥品去污代理商 Chemical precipitates found in the press section are inorganic as well as organic.在壓水部的化學藥品沉澱物，無機物和有機物都有 The organic or hydrophobic types include rosin size, wet strength resin, pitch and hydrocarbon oil. 有機物或是抗水型的化藥包括松香、濕強劑、樹脂和碳氫化合物的油 Inorganic precipitates include clay, calcium carbonate, titanium dioxide and alum.無機物的沉澱包括泥土、碳酸鈣、二氧化鈦和明礬。 Chemical Conditioning In general, chemicals for cleaning felts are applied using either a continuous or a shutdown cleaning method. 一般而言，清潔毛毯的化學藥品有兩種應用方法，連續式的清洗或停車時的清洗 Continuous cleaning effectively keeps the felt open during its run rather than relying on the more difficult job of cleaning a plugged felt, i.e., PREVENTION.連續式的清洗能有效的讓毛毯在運轉時保持通暢，而不是依賴較困難的方法：清洗阻塞的毛毯。換言之即預防 CAUTION : Chemicals can pose health and damage risks ; consult your chemical supplier for proper usage.警告：化學藥品會造成影響健康和受傷的風險，請教你的化學藥品供應商適當的使用方法。 Chemical Cleaning Information Chemical cleaning procedure. 化藥清潔的程序 Same wash routine for Acid-alkaline and Hypo. 依照慣例的清潔方法，來使用酸、鹼或次氯酸鹽 Hypo Felt Wash Procedure Continuous Cleaning Guidelines RESOURCE REQUIREMENTS Tape Measure Measuring Wheel Vacuum Gauge Air Flow Meter Press Tuner and/or Water Perm Tension Meter NDC - Head only * Batch cleaning formula guideline 清洗公式的指導方針 Use goggles, respirator and other protective equipment.使用護目鏡、口罩以及其它保護設備 15% solution - Sodium Hypochlorite - 10 litres. 15%的溶劑 – 次氯酸鈉10公升 Lukewarm water - 200 litres. 微溫- 200公升的水 Mix in 215D barrel only. Add Sodium Hypochlorite to barrel of water. 僅在215D的大桶混合，增加次氯酸鹽來將水裝桶 First Step Wash Second Step Wash Running Time (Min.) 20 10 Machine Speed Slow/Crawl - 60 mpm Slow/Crawl Chemical Shower On Off Adjust regulator - 1 kg/sqcm so that 200 litres lasts about 10 minutes. Up to 2 barrels can be used. Rinse Showers Off On Try to get shower temperature - 40°C Vacuum Pumps, Press, P