电站风机出力不原因浅析.docVIP

/ / / / 电站风机出力不足原因浅析 摘要：通过对出力不足影响电站风机长期稳定运行的实际问题分析其原因，提出解决问题的具体措施。 关键词：出力不足；电站风机；稳定运行 Analysis of the Reason of Output Shortage in Power Plant Fan Abstract: Output shortage is a common problem that effect the fan’s continued and stable operation in power plant. The root cause of output shortage is analyzed in this article through some practical problems, this article brings up the specific measures, and probably provides some ideas to solve this problem. 0 引言 0 the introduction 　　风机是电厂的主要辅助设备之一，由于风机故障引起发电机组非计划停运和非计划降低出力运行造成的发电损失是巨大的，出力不足是影响电站风机长期稳定运行的常见问题。通常我们遇到出力不足现象，都是认为风机出力不够，风机或电机选型偏小，而实际情况并非如此，造成风机出力不足的原因很复杂，如何找到风机出力不足的根本原因，从而彻底的解决问题，这是本文讨论的主要内容。本文将通过理论研究和现场实例分析风机出力不足的根本原因。 Fan is one of the main auxiliary equipments of power plant, due to fan failure generating set not plan to stop works and the plan to reduce the output power loss is huge, is insufficient output capacity of common problem fan, long-term stable operation of the power station. Output shortage phenomenon, usually we met were thought the fan power is not enough, small fan or motor selection, and its actually not the case, the causes of the insufficient fan output is very complex, how to find root cause of the fan power, so as to thoroughly solve the problem, it is discussed in this article the main content. This article through the theoretical research and field fan output less than the root cause of the case analysis. 　　1 实例概述 1 instance overview 　　某电厂210MW工程火电机组670t/h锅炉配置2台冷一次风机，风机为单吸双支撑离心式通风机，设计参数见表1。　168试运中，风机调节门不能全开，在开度75%时电流已接近或超过额定电流，风机出力不足，不能安全稳定的满足机组210MW负荷要求。 210 mw thermal power unit engineering configuration two 670 t/h boiler cooling fan, a fan for the single suction double support centrifugal ventilator, the design parameters are shown in table 1. Fan damper can not fully open, start-up in 168, 75% in the opening when the current is close to or more than the rated current, the fan power is insufficient, cant secure and stable to meet the requirements of 210 mw unit loa