镜铁矿细粒粉矿制粒-回转窑磁化焙烧及分选研究-矿业工程专业论文.docxVIP

AbstractFine Abstract Fine specularite from JISCO has complex mineral composition and dissemination relationship．It is difficult to use conventional concentration process to treat effectively Magnetic roasting is the most effective method to deal with such fine ore at present，and magnetic roasting with rotary kiln is reasonable．But the fine ore，especially the 0-1 mln， cannot access to rotary kiln directly while the grinding and pelletizing may cause the grade lower,process more complex and cost higher,the application is limited．In this paper,combined with the characteristics of such fine ore，granulation and magnetic roasting with rotary kiln process is used to simplify the process and reduce costs and obtain a good beneficiation indexes at the same time．Then the roasting and sorting process factors which would have an influence on the grade of concentrate have been studied． The main iron minerals of fine specularite are specularite，siderite and limonite， and the gangue minerals are mainly quartz，jasper and ankerite．The mineral composition and disseminated relationship of the fine specularite is complex，because the iron minerals’fine disseminated extent and part of the gangue mineral contain iron． It is difficult to separate by conventional concentration process． Under the condition of 1．2 wt％bentonite and 8 wt％water and granulation for 1 0 minutes，the size of granulation is 3-5 mm．After drying，under the condition of 20％ filling rate and 2．5 wt％，roasting at 750。C for 60 minutes Can obtain a good ore dressing indexes，the grade of iron is 53．0 1％and the recovery is 87．66％．Analyzing the process of roasting combined with the XRD analysis，verifying the roasting temperature is reasonable．Roasting process changed the iron phase and mineral structure，but didn’t change its dissemination．The 0-1 mm fraction of granulation increased only 6．78％．SO the pulverization rate is low． The effect ofmagnetic roasting of西O．65-0．45x9 m variable diameter rotary kiln is II 万方数据 the the be