不同水泥含量及级配乳化沥青就地冷再生混合料疲劳特性研究刘.pdf

不同水泥含量和级配的乳化沥青就地冷再生混合料疲劳特 性研究 刘照明 1,2 辜晨飞 1,2 (1. 中船第九设计研究院工程有限公司 , 上海 200063 ； 2.上海海洋工程和船厂水工特种工程技术研究中心，上海 200063) 摘要： 采用半圆弯曲疲劳试验和间接拉伸疲劳试验对乳化沥青就地冷再生混合料在不同应 力比下的疲劳性能进行研究，主要分析水泥含量和级配对乳化沥青就地冷再生混合料疲劳 性能的影响，并与热拌沥青混合料进行对比。结果表明：首先，依据半圆弯曲疲劳试验结 果，水泥含量较高有利于乳化沥青就地冷再生混合料在低应力比下的疲劳性能，而对高应 力比下的疲劳性能不利；其次，依据间接拉伸疲劳试验结果，级配对普通热拌沥青混合料 的疲劳性能影响较大，对乳化沥青冷再生混合料疲劳性能影响不大，并且相同应力比下， 乳化沥青就地冷再生混合料的疲劳寿命要长于普通热拌沥青混合料。 关键词： 乳化沥青就地冷再生混合料；疲劳性能；水泥含量；级配 Fatigue Performance of Emulsified Asphalt Cold In-place Recycled Mixture considering varying cement contents and gradations 1,2 1,2 Liu Zhaoming Gu Chenfei （1.China shipbuilding NDRI Engineering Co., Ltd., Shanghai 200063, China; 2.Shanghai Research Center of Ocean & Shipbuilding Engineering, Shanghai 20063, China) Abstract: To study the fatigue performance of Emulsified Asphalt Cold In-place Recycled Mixtures (CIR) at different stress levels, semi-circle beam fatigue test (SCB) and indirect tensile fatigue test (IDT) was conducted. The influence of cement content as well as nominal maximum aggregate sizes on the fatigue lives of CIR was analyzed and fatigue lives of hot mix asphalt mixtures (HMA) were also tested to compare with the fatigue performance of CIR. Results demonstrates that higher cement content is beneficial for the fatigue resistance of CIR at low stress level, but detrimental to the fatigue resistance of CIR at high stress level. Nominal maximum aggregate sizes have negligible impact on the fatigue lives of CIR. At the same stress level, the fatigue lives of CIR is longer than HMA. Keywords: Emulsified Asphalt Cold In-place Recycled Mixtures; Fatigue Performance; Cement content; nominal maximum aggreg