水压试验作业安全风险分析.docVIP

LOGO LOGO 项目名称 Docume nt No. HSE-JSA-000 LOGO LOGO 项目名称 Docume nt No. HSE-JSA-000  SL # SEQUENCE OF BASIC JOB STEPS POTENTIAL HAZARDS REQUIRED HAZARDS CONTROL 01 水压试压及检查 Water pressure test and in specti on 球罐泄压伤人 Pressure leak ing of spherical tank caus ing harm 试压时划定警戒区，拉警戒绳，挂 “试压危险”警戒牌，并设专人负 责警戒，非试压人员不得入内。 Warning area should be set up when test pressure , warning rope , warning sig n dan ger for testing pressure ” , specific pers onnel be in charge preve nt outsider come in side testi ng area . 试压过程中如果发现泄漏点，不得 进行带压修补及紧固，试压管线带 压时禁止踩踏和敲击。 Repair and tightening are not allowed with pressure on when leaki ng points are found during test , steping on and knocking are not allowed on  testi ng pipeli ne with pressure on . 水压试验现场用电 触电 试压机具由专人操作。 02 Specific operator for air Electricity applicati on duri ng water pressure test electricity shock compressor 电源线绝缘良好，设备接地良好， 且配置三防插座和漏电保护开关， 操作者应穿绝缘鞋。 Power supply should be in sulated , ground lead for equipme nt and attached three way prevention of socket as well as electricity leak ing protecti on , operator should wear in sulati on shoes . 电气: 业。 施工时按用电操作规程进行作 Operate electricity and gas should follow relava nt procedure . ] 1 03 高处作业 High level operati on 高空坠落 fall from height 高空, 品。 作业必须正确佩戴劳保防护用 Man datory wear of protective applia nces whe n operate at high level 脚手架搭设要先验收后使用。 Buildi ng of scalfold should put into use only after in specti on 监护人不得擅自离岗，时时刻刻了 1  解咼空作业者的动态。 Supervisor should not leave their job , keep an eye or operati onal status all the time 1 Un loadi ng for goods and materials: 水压试验作业 Work Locati on: (LPG 罐区) Prepared by: (Sub -con tractor) Reviewed by: (Co ntractor) Approved by: (Clie nt)