水压试验作业安全风险分析(JSA).docVIP

水压试验作业安全风险分析(JSA) 水压试验作业安全风险分析(JSA) PAGEPage PAGE 3 of NUMPAGES 3 水压试验作业安全风险分析(JSA) LOGO LOGO 项目名称 Document No. HSE-JSA-000 SL # SEQUENCE OF BASIC JOB STEPS POTENTIAL HAZARDS REQUIRED HAZARDS CONTROL 01 水压试压及检查 Water pressure test and inspection 球罐泄压伤人 Pressure leaking of spherical tank causing harm 试压时划定警戒区，拉警戒绳，挂“试压危险”警戒牌，并设专人负责警戒，非试压人员不得入内。 Warning area should be set up when test pressure , warning rope , warning sign “danger for testing pressure” , specific personnel be in charge prevent outsider come inside testing area . 试压过程中如果发现泄漏点，不得进行带压修补及紧固，试压管线带压时禁止踩踏和敲击。 Repair and tightening are not allowed with pressure on when leaking points are found during test , steping on and knocking are not allowed on testing pipeline with pressure on . 02 水压试验现场用电 Electricity application during water pressure test 触电 electricity shock 试压机具由专人操作。 Specific operator for air compressor 电源线绝缘良好，设备接地良好，且配置三防插座和漏电保护开关，操作者应穿绝缘鞋。 Power supply should be insulated , ground lead for equipment and attached three way prevention of socket as well as electricity leaking protection , operator should wear insulation shoes . 电气施工时按用电操作规程进行作业。 Operate electricity and gas should follow relavant procedure . 03 高处作业 High level operation 高空坠落fall from height 高空作业必须正确佩戴劳保防护用品。 Mandatory wear of protective appliances when operate at high level 脚手架搭设要先验收后使用。 Building of scalfold should put into use only after inspection 监护人不得擅自离岗，时时刻刻了解高空作业者的动态。 Supervisor should not leave their job , keep an eye on operational status all the time Unloading for goods and materials: 水压试验作业 Work Location: (LPG罐区) Prepared by: (Sub -contractor) Reviewed by: (Contractor) Approved by: (Client)