掺活化钼尾矿发泡水泥的制备研究.pdfVIP

第 卷第 期 45 6 非金属矿 Vol.45 No.6 2022年 11月 Non-Metallic Mines November, 2022 掺活化钼尾矿发泡水泥的制备研究 * 李  峰  崔孝炜  刘  东  狄燕清  王之宇  杨  晋    （商洛学院陕西省尾矿资源综合利用重点实验室，陕西 商洛 726000） 摘 要 以硅酸盐水泥为主要原料，掺杂活化钼尾矿（AMoT ）制备发泡水泥。研究了活化钼尾矿掺量、发泡剂用量、水灰比和纤维用量对样 品性能的影响，结果表明，当AMoT 掺量为20 %，发泡剂用量为6%，水灰比为0.55，聚丙烯纤维用量为0.35% 时，发泡水泥样品养护28 d ，抗压强度 为1.68 MPa ，气孔率为32.4%。掺入AMoT 起到一定填充作用，使气孔有所改善，有利于提高体系强度。 关键词 钼尾矿；硅酸盐水泥；发泡水泥；抗压强度；气孔率 TQ172.71 TU525 A 1000-8098(2022)06-0094-03 中图分类号： ； 文献标志码： 文章编号： Research on Preparation of Foamed Cement with Activated Molybdenum Tailings * Li Feng Cui Xiaowei Liu Dong Di Yanqing Wang Zhiyu Yang Jin (Shaanxi Key Laboratory of Comprehensive Utilization of Tailings Resources, Shangluo University, Shangluo, Shaanxi 726000) Abstract Foaming cement was prepared from silicate cement and activated molybdenum tailings(AMoT). The effects of the content of AMoT, foaming agent, water cement ratio and fiber on the properties of the samples were studied. The results show that when the content of AMoT is 20%, the foaming agent is 6%, the ratio of water to cement is 0.55 and the fiber is 0.35%, the compressive strength and porosity of the foaming cement sample after curing for 28 days is 1.68 MPa and 32.4%, respectively. The addition of AMoT plays a certain filling role and improves the porosity, which is con- ducive to improving the strength of the system. Key words molybdenum tailings; silicate cement; foamed cement; compressive strength; porosity 发泡水泥是一种新型无