配煤对成浆性的影响.docVIP

配煤对淮南煤成浆性能的影响 摘要 淮南煤煤质优良，可以制出浓度70%左右的水煤浆，但淮南煤灰熔融温度过高，不适合淮化集团近年引入的德士古水煤浆气化炉的液态排渣工艺温度要求。针对水煤浆加压气化过程中的高灰熔融温度煤种，进行了配煤实验研究，结果表明，通过配煤可有效降低煤样灰熔融温度，同时其成浆性能得到改善，对实现水煤浆加压气化原料多样化及煤炭资源的合理利用具有重要的现实意义。 不同变质程度的煤混配，可相应改善煤种的成浆性能，提高制浆浓度，而煤样的反应活性并不会受大的影响，利用淮南煤与蒙煤和华亭煤配煤制浆可以有效提高蒙煤和华亭煤的制浆浓度，一般在同等粘度下可以提高3%～8%，但不同煤种配煤制浆结果有一定的差异。 关键词：德士古，配煤，灰熔融温度，水煤浆，成浆性 EFFECT OF COAL BLENDING ON THE ABSTRACT Huainan coal fine can be produced about 70% of the concentration of coal-water slurry, but the Huainan coal ash fusion temperature is too high, not suitable for Huaihua Group introduced in recent years, Texaco Gasifier Slag-tap coal-water slurry process temperature requirements. For the process of coal-water slurry pressurized gasification melting temperature of the high-ash coal, a coal blending experimental research results show that coal can reduce the melting temperature of coal as that the same time its performance has improved slurry ability for achieving water coal slurry pressurized gasification raw material diversity and the rational utilization of coal resources has important practical significance. Different mixtures of coal rank,corresponding to the coal slurry to improve performance, increase the pulp concentration, and reactivity of coal and will not be affected by alargeimpact on the use of Huainan coal and coal-Mongolian coal and coal pulp Huatingcan effectively improve the Mongolian Huating coal and coal pulp concentration, generally in the same viscosity can be increased by 3% to 8%, but the results of pulp blending different coals have some differences. KEYWORDS:Texaco gasification，coal blending，ash melting point， coal-water slurry 目录 摘要 I ABSTRACT II 绪论 1 1文献综述 2 1.1我国的能源概况 2 1.2Texaco水煤浆气化工艺 2 1.2.1水煤浆气化技术 2 1.2.2Texaco气化工艺简介 2 1.2.3Texaco水煤浆气化的技术特点 4 1.2.4Texaco水煤浆气化技术的应用 5 1.2.5Texaco气化对煤质的要求 5 1.2.6Texaco对水煤浆性能的基本要求 5 1.3影响水煤浆流变特性的因素 6 1.4配煤对煤的灰熔融性和成浆性能的影响 8 1.5水煤浆的应用及研究现状 9 1.5.1水煤浆的应用概述 9 1.5.2水煤浆添加剂的研究现状 9 1.6研究内容 10 2实验部分 11 2.1实验原料 11 2.2实验方法 12 2.2.1灰熔融温度测定 12 2.2.2水煤浆成浆