六区脚手架施工方案.docVIP

10-YB-ISPⅡ-SHF-204 扬子巴斯夫 脚手架搭设施工方案 合同号： A4DT-90-C435//IPS-1000-20-435 CONTRACTNO: A4DT-90-C435//IPS-1000-20-435 编制prepared by ： 审核reviewed by： 批准approved by： 南京南化建设有限公司 Nanjing Chemical Construction Co., Ltd. , 2010 Table of Contents 目 录 工程概况 Project Introduction 二、编制依据Reference．脚手架搭设施工工艺Scaffold Erection Procedure 、脚手架搭设基本要求：Basic Requirement脚手架搭设形式和图例 and Sketch for Scaffolds Erection 七. 脚手架搭设安全要求及措施Safety Requirement and Measures 、脚手架的拆除Scaffolding ．现场脚手架搭设管理机构Organization Chart of Scaffold Erection Management 一工程概况 Project Introduction1. 扬子石化巴斯夫IPS II 2. 本工程以管廊钢结构安装、管道安装、管道试压吹扫、配电室/控制室盘柜安装、桥架安装、电缆安装、储罐安装、球罐安装等工作为主，为了顺利进行，高空作业必须搭设操作平台，施工过程中应严格遵照脚手架的搭设工艺、高空作业安全规程以及IET对本工程的规范要求，避免安全事故的发生和保障施工人员的人生安全是本工程的宗旨。为此编制本施工方案，以便保质保量的完成本分项工程。本工程脚手架搭设主要采用钢管扣件式脚手架和移动式脚手架两种，其中脚手架搭设形式主要以钢管扣件式悬挂脚和落地式脚手架为主。This project mainly involves modification of structural steel, piping and its pressure test, flushing and blowing, panel in power distribution room/ control room, cable tray and cable. Operation platform shall be erected for work at height to a smooth construction, steel sheeting plate shall be used for the segregation of production area from construction area, full hall steel plank scaffolding shall be performed on the top roof of some equipments. Fire proof cloth shall be provided for the required area in accordance with owner′s requirements. The whole construction process shall be strictly proceeded in accordance with scaffolding erection and work at height safety specification as well as IET requirements and specifications, as to avoid accidents and guarantee personnel safety. Scaffold used for this project will be steel-tube with two types, tube-coupler and movable. The built type will be coupler suspended and ground mounted. 二、编制依据Reference GB/T13793 Straight seam weld pipe直缝电焊钢管 GB/T700 CS structural steel碳素结构钢 GBJ50009—2001 Building’s load code 建筑结构荷载规范 GB15831 Coupler for Steel tube scaffolding 钢