塞拉尼斯ChinaLite项目管桩试桩工程施工方案.docVIP

塞拉尼斯China Lite项目 Lubrizol Additive (Zhuhai) Co., Ltd Phase I II Project 管桩试桩工程施工方案 Tubular Pile Engineering Construction Method Statement 项目编号：CC1117F1209-CON-004 No.： CC1117F1209-CON-004 （版次：0版） (Revision: 0) 湖南省建筑工程集团总公司 CNCEC 14th Zhuhai LZA Project Management 2012年02月20日 Feb 20, 2012 目 录Table of Content 目 录Table of Content 1 1． 编制说明 Compilation Specification 3 1.1编制依据 Basis of Compilation 3 1.2采用规范、标准 Regulation Standard Applied 3 2． 工程概况 Engineering Profile 4 2.1项目概况 Project Profile 4 2.2工程量一览表 Bill of Quantities 4 3． 施工组织部署 Construction Organization Allocation 6 3.1 施工技术准备 Construction Technical Preparation 6 3.2施工现场准备 Project Site Preparation 9 3.3施工物资准备 Construction material preparation 10 3.4资源配备计划 Resource Allocation Plan 11 3.5工程进度计划 Project Progress Plan 13 4． 施工顺序 Construction sequence 14 5． 施工测量 Construction Measurement 15 5.1测量一般要求 General Requirement for Measurement 15 5.2测量控制原则 Measurement Control Principle 15 5.3测量方法 Measurement Method 15 5.4测量质量标准 Measurement Quality Standard 16 6． 主要施工方法 Main Construction Method 17 6.1工艺流程 Process Flow 17 6.2施工方法 Construction Method 20 6.2.1 桩位放样 Pile Location Set Up 20 6.2.2桩机就位 Piling Machine In Position 20 6.2.3管桩堆放 Tubular Pile Stacking 20 6.2.4吊桩插桩 Pile lifting and planting 20 6.2.5垂直度调整 Verticality Adjustment 22 6.2.6静压沉桩 Static Sinking Pile 22 6.2.7沉桩过程中遇块石的应急处理措施 Emergency countermeasures against heavy stones during pile sinking 23 6.2.8接桩连接 Pile Splicing 24 6.2.9沉桩控制 Double Control on Sinking Pile 26 7． 质量保证措施 Quality Assurance Measure 27 7.1质量岗位责任制度 Quality Occupational Responsibility System 27 7.2质量专项检查制度 Quality Specific Inspection System 27 7.3施工过程控制措施 Control Measure During Contraction Process 29 8． HSE管理措施 HSE Management Measure 33 8.1主要危险源及环境因素识别Major Hazard Environment Factor Identification 33 8.2 HSE管理措施 Management Measure 33 8.3 HSE技术措施 HSE (Health Safety Education) Technical Measure 35 8.4桩机管理措施 Piling Machine Management Measure 37 8.4.1桩机管理台帐 Piling Machine Management List 37