水泥稳定再生废砖块集料性能分析研究.pdfVIP

Study on the performance of cement stabilized recycled crushed bricks Aggregate A Dissertation Submitted for the Degree of Master Candidate：Chen Chaojin Supervisor：Associate Prof. Hu Liqun Chang’an University, Xi’an, China I 摘 要 近年来，建筑垃圾与日俱增，其合理有效的利用是缓解资源短缺和环境污染问题的 有效途径。本文研究了碎砖块集料的物理性能以及掺入碎砖块集料后水泥稳定碎石的力 学性能、抗冻性和疲劳性能。 研究结果表明： 破碎集料颗粒主要集中在4.75cm 和 9.5cm 之间，细集料很少。碎砖块集料的针片 状颗粒含量是33.6%，吸水率为19.67%，压碎值为29.3% ； 击实试验表明：碎砖块集料掺量增加，最大干密度呈降低趋势，最佳含水量呈增加 趋势； 碎砖块集料掺量增加，无侧限抗压强度、劈裂强度、抗压回弹模量以及抗弯拉强度 呈减小趋势，但是随养生龄期增加呈增加趋势； 抗冻性随着水泥剂量提高呈增强趋势，随着废砖块集料掺量增加呈降低趋势； 疲劳寿命随着水泥剂量提高呈增强趋势，随着废砖块集料掺量增加呈降低趋势； 通过对比规范中各级公路对水泥稳定碎石7 天无侧限抗压强度要求，在水泥剂量为 5%，集料级配接近中值，严格控制掺入比例的情况下，碎砖块集料可应用于各等级公 路基层或者底基层。 关键词：水泥稳定碎砖块集料；强度；模量；抗冻性能；疲劳寿命 I Abstract In recent years, construction waste has been increasing. Rational and effective use is an effective way to alleviate the shortage of resources and environmental pollution problems. The paper studies systematically the physical properties, mechanical properties, freezing resistance and fatigue properties of the recycled crushed brick aggregate. The main contents and results as follows: Aggregate particles are mainly concentrated in the 4.75cm and 9.5cm, and fine aggregate is rare. Flat and elongated particles in coarse aggregate is 33.6%.The water absorption of recycled aggregate is 19.67%. Crushing value is 29.3%. The experiment results show that dry density of cement stabilized recycled aggregate increases with the growth of content of recycled aggregate ，and moisture content reduces ． Unconfined compressive strength ，splitting strength ，flexural strength and