布袋除尘中英文对照使用维护说明.docVIP

扁 布 袋 除 尘 机 组 安装使用注意事项 The Installation and use of attention of the product 安装前应检查机组的完好性，重新拧紧各部位连接螺栓； Before the installation, should check the reliability of the machine group, and tighten each part of the connecting bolts 安装位置务必注意检查门开启方便，保证预留足够检修空间； The installation location of the machine must match the switch of inspection door opens conveniently, ensure enough maintenance space 机组底部需垫10mm厚的防震胶垫，风机调试时应注意正反转，注 意保持风机的平衡度，风管与风机连接处要采用软连接的方式，以降低噪音； The bottom of the machine must be mat 10mm thick shockproof pads, the positive negative should be payed attention to when debug fan, keep the balance, air blower fan joint with the way to adopt soft connection, in order to reduce noise, 调试时要手动调节振打装置连接件，确保振打时的力度均衡，力 度过大时，会大大缩短布袋的使用寿命，机组的噪声也会超标，力度过小时，会造成布袋积灰过多，阻力增大，除尘器处理风量会大大降低，且长时间的积灰过厚也会缩短布袋使用寿命，增大检修时清扫及更换难度。 Fitting manual adjustment, when commissioning vibrating device, ensure the vibrating force equilibrium, if the strength of the device is over, can greatly shorten the bag, and the noise will exceed the standard, or if the strength is undersize, will caused the bag excessive deposited bag dust, resistance increases, the dust catcher will reduce the working efficiency, and if the dust being too thick for a long time, it will shorten the machine’s life, and increase the difficulty of cleaning and replace the machine. 除尘机组的安装尽量达到水平。 Make sure the installation of the machine can up to par 布袋除尘机组的维护与检修说明 除尘系统工作时，应使机组的风量保持在额定风量左右且尽量减 少风量的波动； While the dedusting system working, should keep the input air of the machine around the rating data and try to reduce the wave motion of air 经常注意保持各检查门的严密性； Often keep the switch of inspection door of rigor 经常检查排风口的出风洁净情况，如发现排风口有大量灰尘排出，即表明布袋严重破损，应及时检修、清扫或更换布袋，定期可进行手动操作振打装置，以清扫布袋积灰； Always check the condition of the vents,if there is large quantity dust was discharge namely that machine should be timely maintenance, serious breakage, you should clean or replace bag in time, you also can use the vibrating device by hand movement to c