BDA-ENG-002 Compressed air system equipment maintenance空气压缩机维保标准.docVIP

介绍 这个程序的目的是描述施乐辉外科植入物（北京）有限公司空气压缩机设备维修计划及设备维护程序由此观察设备的性能。 The program aims to introduce Smith-Nephew Orthopedics Beijing Co. Ltd.’s air compressor system maintenance plan and equipment maintenance procedures so as to observe the equipment’s performances. 范围Scope 施乐辉外科植入 物（北京）有限公司空气压缩机设备 Smith-Nephew Orthopedics Beijing Co. Ltd.’s air compressor system 参考Reference 《操作》 peration and maintain Instruction 《设备维护保养工作记录单》BENG004-F002 “Equipment maintenance record” BDAENG004-F002 定义Definite 不适用。N/A 5. 要求 Requirement 5.1 日常5.1.1 操作者空气压缩机设备前,应对空气压缩机原理有所了解，严格按照《》要求操作,严禁违章操作 Before operation of air compressor equipment by operator, the principle of air compressor shall be understood and it shall be operated in strict accordance with requirements in the “Compressed air equipment manual”, operation against rules is prohibited. 5.1.2 空气压缩机设备投入运行，操作人员应2小时1次，注意压力、流量、电压、电流是否正常，有无跑水现象，发现问题应及时调整和处理Upon the air compressor equipment put into operation, the operator shall inspect it regularly, pay attention to whether pressure, flow, voltage, current is normal, and whether there is water leakage, if there is problem found, adjustment and disposal shall be made in time. 5.2 日常维护、保养 Daily Maintenance 5.2.1 空气压缩机Air Compressor 5.2.1.1 清除电机内油泥Remove oil sludge within the motor 5.2.1.2 各运动部件加注润滑油 Filling lubricant for all moving parts 5.2.1.3 检查轴承是否正常Check whether the bearing is normal 5.2.1.4 摇测电机绝缘Motor insulation test shaking 5.2.1.5 紧固各接线端子Terminal block fastening 5.2.2 电器元件Electrical components 5.2.2.1 检查各接线点有无变色打火现象Check phenomenon of color changing and ignition at connection points 5.2.2.2 清理电气灰尘Electric dust clean-up 5.2.2.3 检查各活动件是否动作灵活Check whether all moving parts are flexible 5.2.2.4 紧固各连接点Fasten connection points 5.2.3 设备外观Appearance of equipment 5.2.3.1 擦去外观灰尘Wipe appearance dust 5.2.3.2 检查外观有无破损变形Check deformation damage on appearance 5.2.3.3 检查外观有无破损掉漆Check damage and paint falling on appearance 5.2.3.4 设备连接件做防腐处理Antiseptic treatment on joints of equipment 5.2.4