皮带输送机操作使用全技术-斗式提升机.docVIP

皮带输送机操作使用安全技术 1．固定式皮带输送机应安装在坚固的基础上；移动式皮带输送机在运转前，应将轮子对称楔紧。多机平行作业时，彼此间应留出1m以上的通道。输送机四周应无妨碍工作的堆积物。 2．启动前，应调整好输送带松紧度，带扣应牢固，轴承、齿轮、链条等传动部件应良好，托辊和防护装置应齐全，电气保护接零或接地应良好，输送带与滚筒宽度应一致。3．启动时，应先空载运转，待运转正常后，方可均匀装料。不得先装料后启动。4．数台输送机串联送料时，应从卸料一端开始按顺序启动，待全部运转正常后，方可装料。 5．加料时，应对准输送带中心并宜降低高度，减少落料对输送带、托辊的冲击。加料应保持均匀。6．作业中，应随时观察机械运转情况，当发现输送带有松弛或走偏现象时，应停机进行调整。 7．作业时，严禁任何人从输送带下面穿过，或从上面跨越。输送带打滑时，严禁用手拉动。严禁运转时进行清理或检修作业。8．输送大块物料时，输送带两侧应加装料板或栅栏等防护装置。9．调节输送机的卸料高度，应在停车时进行。调节后，应将连接螺母拧紧，并应插上保险销。 10．运输中需要停机时，应先停止装料，待输送带上物料卸尽后，方可停机。数台输送机串联作业停机时，应从上料端开始按顺序停机。 11．当电源中断或其他原因突然停机时，应立即切断电源，将输送带上的物料清除掉，待来电或排除故障后，方可再接通电源启动运转。12．作业完毕后，应将电源断开，锁好电源开关箱，清除输送机上砂土，用防雨护罩将电动机盖好。             吷噢吺 斗式提升机 thrift of excellent traditional and style lack deep of understanding, one-sided think in now of good situation Xia, economic smooth more fast development, and reform made major progress, and people living significantly improve, and social the career made new progress, no necessary always hard has, no awareness to China also has many poverty area, and also has many poverty population of exists, more living improve has, more need keep hard of style. Three is not strictly honest. 　　Total thought units is a water sector, clean self-discipline away from himself too far, no real processing good living of improve and hard, and thrift excellent traditional of relationship, no effective do comply with Constitution and party of regulations must from I do up, no right mercy good bitter Le, and wealth of relationship, no right awareness to in comply with Constitution and party of regulations aspects everyone has accountability. Four, future direction and improvement measures 1, belief and faith, strengthen party spirit. One is to firmly establish the noble ideals of struggle f