1025t／h锅炉低氮燃烧器改造及燃烧调整试验研究.pdf

学兔兔 第5期 锅 炉 制 造 No．5 2015年9月 B0ILER MANUFACTURING Sep．2015 1 025 t／h锅炉低氮燃烧器改造及燃烧调整试验研究 张文年，陈 聪，文萃萃，李 洋，徐有宁 (沈阳工程学院能源与动力工程学院，辽宁沈阳110136) 摘 要：氮氧化物是火电厂的主要污染物之一，随着大气污染物排放标准的提高，低氮燃烧技术成为学术研究 的热点。本文以某电厂低氮燃烧器改造为例，对改造措施和效果进行了研究，研究结果表明：采用二次风垂直 分级高位燃尽风系统及“风包粉”技术联合应用能够较好的降低NO 含量，改造后氮氧化物的排放由原来的 854 mg／Nm 变为460 mg／Nm。，锅炉效率由原来的91．22％提高到92．48％，改造取得了良好的效果。 关键词：低氮燃烧器；燃烧器改造；燃烧调整 中图分类号：TK223．23 文献标识码：A 文章编号：CN23—1249(2015)05—0001—04 Experimental Study on Low NOx Burner Transformation and Combustion Adjustment of 1 025 t Boiler Zhang Wennian，Chen c0 ，Wen Cuicui，Li ，Xu Youning (School of Energy and Power Engineering，Shenyang Institute of Engineering，Shenyang 110136，China) Abstract：Nitrogen oxides are one of main pollutants in thermal power plant．With the implementa- tion of the new version of the atmosphere pollutants emission standards in the power plant，it is more strict to power plant emissions，especially NOx emissions．Therefore，the transform of the Stereo hier- archical low nitrogen burner is necessary．This paper discusses the transform of the Stereo hierarchi． cal low nitrogen burner in the plant，and the measures and effects of the transform were studied．The results show that，The secondary air vertical grade high burning system and“wind powder”technolo— gY combined application can reduce the content of NOx．The nitrogen oxide emissions reduced from 854 mg／Nm into 460 mg／Nm after the transform ，and the efficiency of the boiler increased from the