基于EXB841的改进型IGBT驱动保护电路.pdfVIP

学兔兔 总第47卷 第533期 电测与仪表 Vo1．47 No．533 2010年 第05期 Electrical Measurement Instrumentation May．2010 基于EXB84 1的改进型IGBT驱动保护电路 王君惠，陈希有，牟宪民 (大连X_r-大学 电气工程学院，辽宁大连 116024) 摘要：简要介绍了IGBT高速驱动模块EXB841的工作原理，针对典型驱动电路中存在的不足，提出了利用稳压二 极管降低过流检测阈值电压、增加过流故障信号锁存电路对故障信号进行封锁、采用外部电路产生负栅压来解 决内部稳压二极管易损坏的有效改进方法。此外，介绍了驱动电路栅极电阻的三种连接方法。经优化设计后的 电路在光伏发电系统的实验平台中进行了应用，结果表明所设计的电路改善了IGBT的驱动和保护性能，具有良 好的实用价值。 关键词：EXB841；锁存电路；栅极电阻；保护 中图分类号：TM40 文献标识码：B 文章编号：1001—1390(2010)05—0072—05 Improved Driving and Protecting Circuit of IGBT Based on EXB841 WANG Jun—hui，CHEN Xi—you，MU Xian-min (School of Electrical Engineering，Dalian University of Technology，Dalian 1 1 6024，Liaoning，China) Abstract：The operating principle of IGBT high speed driving module EXB841 is introduced briefly．According to the shortage of this driving module，some effective improved methods are investigated，including reducing the threshold voltage of over-current protection by using the Zener diode，adding the locking circuit to block fault signal of over-current and using the external grid——voltage generation circuit to solve the damage problems of the inner Zener diode．In addition，three kinds of connection methods to choose different on and off grid resistors in driving circuits are also discussed．The optimum circuit was applied to the prototype of Photovohaic Generation System．The performances of driving and protection of the driver modified by this paper are demonstrated experimentally．Therefore，it would show the potential value in the practical applications． Key words：EXB841，locking circuit， d resistor，protection 0 引 言