卷扬机安全操作规程.docVIP

卷扬机安全操作规程 卷扬机安全操作规程提要：作业中，任何人不能跨越正在作业的卷扬钢丝绳。物件提升后，操作人员不得离开卷扬机，物件或吊笼下面严禁停留或通过。休息时应将物件或吊笼降至地面 更多精品：客服 卷扬机安全操作规程 1、安装时，基座应平稳牢固、周围排水畅通、地锚设置可靠，并应搭设工作棚。操作人员的位置应能看清指挥人员和拖动或起吊的物件。 2、作业前，应检查卷扬机与地面的固定，弹性连轴器不得松旷。并应检查安全装置、防护设施、电气线路、接零或接地线、制动装置和钢丝绳等，全部合格后方可使用。 3、使用皮带或开式齿轮传动的部分，均应设防护罩，导向滑轮不得用开口拉板式滑轮。 4、以动力正反转的卷扬机，卷筒旋转方向应与操纵开关上指示的方向一致。 5、从卷筒中心线到底一个导向滑轮的距离，带槽卷筒应大于卷筒宽度的15倍；无槽卷筒应大于卷筒宽度的20倍。当钢丝绳在卷筒中间位置时，滑轮的位置应与卷筒轴线垂直，其垂直度允许偏差位6°。 6、钢丝绳应与卷筒及吊笼连接牢固，不得与机架或地面磨擦，通过道路时，应设过路保护装置。 7、在卷扬机制动操作杆的行程范围内，不得有障碍物或阻卡现象。 8、卷筒上的钢丝绳应排列整齐，当重叠或斜绕时，应停机重新排列，严禁在转动中用手拉脚踩钢丝绳。 9、作业中，任何人不能跨越正在作业的卷扬钢丝绳。物件提升后，操作人员不得离开卷扬机，物件或吊笼下面严禁停留或通过。休息时应将物件或吊笼降至地面。 10、作业中，如发现异响、制动不灵、制动带或轴承等温度剧烈上升等异常情况时，应立即停机检查，排除故障后方可使用。 11、作业中停电时，应切断电源，将提升物件或吊笼降至地面。 12、作业完毕，应将提升吊笼或物件降至地面，并应切断电源，锁好开关箱。 Measures for the routine management of moral education in Middle SchoolsMethod of conventional management of moral education in middle schoolFirst, the guiding ideology:School moral education is an organic whole of the whole education work, always adhere to the school adhere to the moral education, education for this product, and actively promote the quality education, the school building efficient curriculum system of moral education, moral education, improve the sense of attraction and appeal, enhance the moral education work for through and timeliness. Teach everyone, service education and management education, and school moral education work must be with family education and community education closely together, to form a concerted pattern, and strive to create a good atmosphere for education, and to promote the all-round development of students, to establish a scientific moral education full of vigor the For long-term mechanism.Two, the goal of moral education:To guide the students to form the correct world outlook, outlook on life, values, to cultivate students unity and mutual assistance, honest and trustworthy, law-abiding, good quality, hard work, set a good XX students ideological