施工砂浆拌和机安全技术交底2.docVIP

施工砂浆拌和机安全技术交底2 施工砂浆拌和机安全技术交底2提要：机械发生故障，必须拉闸切断电源停机，将筒内砂浆清出，报告机修组进行检修，排除故障。不准擅自拆除防护装置 自 施工砂浆拌和机安全技术交底2 施工单位： 工程名称分部分项 工程工种 1．进入现场必须遵守安全操作规程和安全生产十大纪律。 2．砂浆机底座应平整稳固，开关箱离操作位置不大于3m，接零保护良好，触电保护器灵敏有效，传动皮带防护罩完好无损。防护棚应符合防晒、防火和抗冲击的要求。 3．操作人员必须持证上岗，穿胶水鞋、戴安全帽和口罩，不准将机交给无证人员开动。 4．砂浆出料应用圆盘式，不得使用倒顺开关。 5．作业前应检查拌和机的传动部份、工作装置、电线电器，防护装置等应牢固可靠，操作灵活，保险丝符合规定要求。 6．启动后，先经空机运转，检查拌叶旋转方向，确认一切正常后，方可边加水边加料进行搅拌作业，不准超规定容量投料，不准先加料满负荷启动。 7．砂浆机在运转过程中，不得用手、脚、木棒、铁铲等伸进拌筒在筒边沿口清理灰浆或扒料，防止拌叶撞击伤人。 8．加入筒内的砂子、石灰等材料必须经过筛选，防止石子、石渣在筒底卡住搅拌叶，造成机械停转，电机发热损坏设备。 9．机械发生故障，必须拉闸切断电源停机，将筒内砂浆清出，报告机修组进行检修，排除故障。不准擅自拆除防护装置。 10．进行机械维修保养时，必须先拉闸切断电源，拔去电源插头，锁好开关箱，挂上”有人维修，严禁合闸”标志，方可检修。入筒内检修时外面必须派专人监护。 11．作业后，应做好拌和机内外的清洁保养及场地清理工作，不准伸手、脚到筒口清洗，注意电动机不得湿水受潮。 12．下班时，必须拉闸切断电源，锁好开关箱。 13．现场补充交底内容： 交底人签字： 日期： 接受人（全员）签字： 注：本交底一式三份，班组、交底人、资料保管员各一份 自 Measures for the routine management of moral education in Middle SchoolsMethod of conventional management of moral education in middle schoolFirst, the guiding ideology:School moral education is an organic whole of the whole education work, always adhere to the school adhere to the moral education, education for this product, and actively promote the quality education, the school building efficient curriculum system of moral education, moral education, improve the sense of attraction and appeal, enhance the moral education work for through and timeliness. Teach everyone, service education and management education, and school moral education work must be with family education and community education closely together, to form a concerted pattern, and strive to create a good atmosphere for education, and to promote the all-round development of students, to establish a scientific moral education full of vigor the For long-term mechanism.Two, the goal of moral education:To guide the students to form the correct world outlook, outlook on life, values, to cultivate students unity and mutual assistance, honest and trust