木工圆锯机安全操作规程（六）.docVIP

木工圆锯机安全操作规程（六） 木工圆锯机安全操作规程（六）提要：锯片上方必须安装保险挡板和滴水装置，在锯片后面，离齿10-15mm处，必须安装弧形楔刀.锯片的安装应保持与轴同心 自建筑施工资料 木工圆锯机安全操作规程（六） 一、操作前应进行检查.锯片必须平整，光滑，无锈，锯齿要尖锐，并有适当的锯路，不得有连续缺齿.锯片如有裂缝时，其长度不得超过20mm，裂缝末端应冲止裂孔，以防继续扩展. 二、锯片上方必须安装保险挡板和滴水装置，在锯片后面，离齿10-15mm处，必须安装弧形楔刀.锯片的安装应保持与轴同心. 三、被锯木料的厚度，以锯片能露出木料10-20mm为限，夹持锯片法兰盘的直径应为锯片直径的四分之一. 四、操作人员应戴防护眼镜，站在锯片一侧，禁止站在和面对锯片旋转的离心力方向操作，手不得跨越锯片. 五、机械启动后，应待锯片转速正常后进行锯料.进料必须紧贴”靠山”，不许将木料左右摇晃或高抬.送料不能用力过猛，遇木节要缓缓送料. 六、锯料长度应不小于500mm，上锯人员的手离锯齿不得少于300mm，接近端头时，应用推棍送料.下手应待木料推出工作台后，才允许接料.接料后不允许猛拉.需要回料时，木料应离开锯片后再回送.锯下的半成品应堆放整齐，边料应集中堆放. 七、锯短料时，一律使用推棍，不得直接使用手推.推料的速度不得太快，用力不得过猛.接料必须使用刨钩.长度不足500mm和超过锯片半径的木料，严禁上锯. 八、如锯线走偏，应逐渐纠正，不得猛扳，以免损坏锯片.如被锯的木料卡住锯片时，应立即停车处理. 九、锯片运转时间过长而温度过高时，应用水冷却;直径600mm以上的锯片在操作中应喷水冷却. 十、锯台要保持清洁.锯台面上的碎料必须随时清除，但严禁用手直接拣拾.清除锯末或调整部件，必须在机械停止运转后再进行.严禁机械运转时作清扫，调整工作. 十一、停车时不准用木棍，木块去按锯片，停稳后要将水擦干防止锯片生锈. 自建筑施工资料 Measures for the routine management of moral education in Middle SchoolsMethod of conventional management of moral education in middle schoolFirst, the guiding ideology:School moral education is an organic whole of the whole education work, always adhere to the school adhere to the moral education, education for this product, and actively promote the quality education, the school building efficient curriculum system of moral education, moral education, improve the sense of attraction and appeal, enhance the moral education work for through and timeliness. Teach everyone, service education and management education, and school moral education work must be with family education and community education closely together, to form a concerted pattern, and strive to create a good atmosphere for education, and to promote the all-round development of students, to establish a scientific moral education full of vigor the For long-term mechanism.Two, the goal of moral education:To guide the students to form the correct world outlook, outlook on life, values, to cultivate students unity and mutual assistance, honest and t