液压电梯维保基本要求.doc

液压电梯维保基本要求 液压电梯维保基本要求提要： 液压电梯与曳引式电梯相同部分的维保要求见第4章的规定,不同部分应符合以下要求: 液压系统 机房禁止烟火标志完好,电气和油液灭火器有效,机房与井道若不毗邻其之间的通讯设备完好。 液压油管无破裂,管接头、油箱及各类阀体无漏油现象。每月检查一次。 过滤器内杂物清理,每半年一次。 电梯升至最高层油量应处于规定位置,每月检查一次。 油缸柱柱塞间无超量渗透油,每月检查一次 安全溢流阀调定工作压力不应超过满负荷压力值的140%,在任何情况下严禁超过满负荷压力值的170%。每半年测试一次。 在停电的状态下,::机房内手动控制的下降阀功能可靠,能将轿厢以不大于/s的速度下降到平层位置。当系统压力低于该阀的压力时,手动下降操作应无效,不得出现驱动、钢丝绳松驰现象。每半年试验一次。 手动泵配置的溢流阀调定压力,不应超过额定压力值的倍。每半年测试一次。 液压系统油温监控装置功能可靠,当油箱油温超过预定值时,该装置应能立即将轿厢就近停靠在平层位置上并打开轿门。只有经过充分冷却之后,液压电梯才能自动恢复上方向的正常运行。 电梯功能试验 ~条款每半年检查一次。 电梯与油泵同步运行试验:驱动油泵的电动机不旋转,液压电梯应停止运行,并保持停车状态。 额定载重量轿厢沉降试验:载有额定载荷的轿厢停靠在上端站,在10min内轿厢下沉距离不超过10mm。 电器防沉降系统试验:当轿厢位于平层面以下最大至开锁区下端的区间内时,无论轿门处于任何位置,都应按上行方向给主机通电,使轿厢向上移动。 限速切断阀试验:装有额定载荷重量的轿厢下行超速,当达到限速切断阀的动作速度时,限速切断阀应可靠动作,其调定速度应符合出厂资料的要求。 对重安全钳试验:轿厢空载、对重以检修速度下行,进行试验,安全钳动作可靠。 耐压试验:对液压系统加以200%的满负荷压力,保持5分钟,液压系统应无明显的压力下降和泄漏。 Measures for the routine management of moral education in Middle SchoolsMethod of conventional management of moral education in middle schoolFirst, the guiding ideology:School moral education is an organic whole of the whole education work, always adhere to the school adhere to the moral education, education for this product, and actively promote the quality education, the school building efficient curriculum system of moral education, moral education, improve the sense of attraction and appeal, enhance the moral education work for through and timeliness. Teach everyone, service education and management education, and school moral education work must be with family education and community education closely together, to form a concerted pattern, and strive to create a good atmosphere for education, and to promote the all-round development of students, to establish a scientific moral education full of vigor the For long-term mechanism.Two, the goal of moral education:To guide the students to form the correct world outlook, outlook on life, values, to cultivate students unity and mutual assistance, honest and trustworthy, law-abiding, good quality, hard work,