混凝土搅拌输送车安全操作规程(五).docVIP

混凝土搅拌输送车安全操作规程(五) 混凝土搅拌输送车安全操作规程提要：启动内燃机应进行预热运转,各仪表指示值正常,制定气压达到规定值,并应低速旋转搅拌筒3~5min,确认一切正常后,方可装料. 自建筑施工资料 混凝土搅拌输送车安全操作规程 一、混凝土搅拌输送车的汽车部分应执行汽车一般安全技术要求的规定. 二、混凝土搅拌输送车的燃油,润滑油,液压油,制动液,冷却水等应添加充足,质量应符合要求. 三、搅拌筒和滑槽的外观应无裂痕或损伤;滑槽止动器应无松驰和损坏;搅拌筒机架缓冲件应无裂痕或损伤;搅拌叶片磨损应正常. 四、应检查动力输出装置并确认无螺栓松动及轴承漏油等现象. 五、启动内燃机应进行预热运转,各仪表指示值正常,制定气压达到规定值,并应低速旋转搅拌筒3~5min,确认一切正常后,方可装料. 六、搅拌运输时,混凝土的装载量不得超过额定容量. 七、搅拌输送车装料前,应先将搅拌筒反转,使筒内的积水和杂物排尽. 八、装料时,应将操纵杆放在”装料”位置,并调节搅拌筒转速,使进料顺利. 九、运输前,排料槽应锁止在”行驶”位置,不得自由摆动. 十、运输中,搅拌筒应低速旋转,但不得停转.运送混凝土的时间不得超过规定的时间. 十一、搅拌筒由正转变为反转时,应先将操纵手柄放在中间位置,待搅拌筒停转后,再将操纵杆手柄放至反转位置. 十二、行驶在不平路面或转弯处应降低车速至15km/h及以下,并暂停搅拌旋转.通过桥,洞,门等设施时,不得超过其限制高度及宽度. 十三、搅拌装置连续运转时间不宜超过8h. 十四、水箱的水位应保持正常.冬季停车时,应将水箱和供水系统的积水放净. 十五、用于搅拌混凝土时,应在搅拌筒内先加入总需水量2/3的水,然后再加入骨料和水泥按出厂说明书规定的转速和时间进行搅拌. 十六、作业后,应先将内燃机熄火,然后对料槽,搅拌筒入口和托轮等处进行冲洗及清除混凝土结块.当需进入搅拌筒清除结块时,必须先取下内燃机电门钥匙,在筒外应设监护人员. 自建筑施工资料 Measures for the routine management of moral education in Middle SchoolsMethod of conventional management of moral education in middle schoolFirst, the guiding ideology:School moral education is an organic whole of the whole education work, always adhere to the school adhere to the moral education, education for this product, and actively promote the quality education, the school building efficient curriculum system of moral education, moral education, improve the sense of attraction and appeal, enhance the moral education work for through and timeliness. Teach everyone, service education and management education, and school moral education work must be with family education and community education closely together, to form a concerted pattern, and strive to create a good atmosphere for education, and to promote the all-round development of students, to establish a scientific moral education full of vigor the For long-term mechanism.Two, the goal of moral education:To guide the students to form the correct world outlook, outlook on life, values, to cultivate students unity a