缓凝剂对C50低氯离子混凝土性能的影响研究.pdfVIP

学兔兔 2014年第 6期(总第 296期 ) 混 凝 土 原材料及辅助物料 Number 6 in 2014(Total No．296) Concrete MATERIAL AND ADMINICLE doi：10．39694．issn．1002-3550．2014．06．014 缓凝剂对C50低氯离子混凝土性能的影响研究 徐长伟。何桂春，孟琦涵 (沈阳建筑大学 材料科学与工程学院，辽宁 沈阳 1 10168) 摘 要：采用三种缓凝剂来研究不同缓凝剂对C50低氯离子混凝土工作性、体积变化、强度和水化热的影响。基于C50高性能混 凝土的设计要求，通过调整优化原料配比来实现混凝土中的氯离子含量在0．06％以下，并通过掺加适量的粉煤灰以达到降低水化热 的目的。研究结果表明：掺加缓凝剂可以有效的减少混凝土的经时损失，同时降低混凝土早期体积变形，并对后期强度无不良影响。 三种缓凝剂中，柠檬酸的缓凝效果比较稳定。 关键词：缓凝剂；低氯离子混凝土；工作性；水化热 中图分类号：TU528．042_3 文献标志码： A 文章编号： 1002—3550(2014)06—0048—03 Research on influence of retarders on the Performance of C50 IOW chloride ion concrete XUChanpvei,]-J~Guichun,MENGQihan (School ofMaterial Science and Engineering，Shenyang Jian Zhu University，Shenyang 1 10168，China) Abstract：The influence ofdifferent kinds ofretarder on the workability，volume change，strength，and hydration heat ofC50 low chloride ion concr~e were studied by using three kinds ofretarders．Based on the design requirements ofC50 high performance concr~e，the content of chloride ion was controlled below O．06％by adjusting and optimizing the mix propo~ion and the hydration heat was reduced by mixing right amount offly ash．The resuRs show that the fluidity loss Can be effectively reduced and at the same time early volum e deformation of concrete Can be lowered without adverse effects on the late strength．Among the three kinds of retarders，the retarding effect of citric acid is stable． Keywords： retarder；low chlorideion concrete；workabilivy；hydrationheat 缓凝剂的使用可减缓水泥水化速率，降低水化热温峰 0 引言