塔机的操作维护要点.docVIP

塔机的操作维护要点 塔机的操作维护要点提要：多台塔机在现场同时工作时，应采用各不同一高度的方法进行，同时司机应高度集中注意，避免塔机相互碰撞，注意塔机周围的建筑物 塔机的操作维护要点 1、机操人员必须持证上岗，熟悉机械的保养和安全操作规程，无关人员未经许可不得攀登塔机。 2、塔机的正常工作气温为-20至+40度，风速低于13m/s。 3、塔机每次转场安装使用都必须进行空载、静载实验、动载实验；静载实验吊重为额定荷载的125%，动载实验吊重为额定载荷110%。 4、夜间工作时，除塔机本身自有的照明外，施工现场应有充足的照明设备。 5、塔吊的操作必须落实三定制，司机的操作规程严格执行。处理电气故障时，须有维修人员以上。 6、多台塔机在现场同时工作时，应采用各不同一高度的方法进行，同时司机应高度集中注意，避免塔机相互碰撞，注意塔机周围的建筑物。 7、塔机应当经常检查、维护、保养，传动部件应有足够的润滑剂，对易损件应经常检查、维修或更换，对连接螺栓，特别是经常振动的零件，应检查是否松动，如有松动则必须及时拧紧。 8、检查和调整制动瓦和制动轮的间隙，保证制动灵敏可靠，其间隙在之间，磨擦面上不应有油污等污物。 9、钢丝绳的维护和保养应严格按GB5144-85规定执行，发现有超过有关规定，必须立即换新。 10、塔机的各结构、焊缝及有关购件是否损坏、变形、松动、锈蚀、裂缝，如有问题应及时修复。 11、各电器线路也应定时检查，是否有老化、故障、损坏等情况，应及时修复和保养。 daily morning exercises or class-break setting-up exercise and discipline inspection and appraisal of public signs;2, daily cleaning and inspection;3, the daily student school appearance, dress, wearing school card check;4, the daily duty guide to the leadership class discipline three rounds.Weekly moral education work:L, the flag raising ceremony and the national flag speech under the flag raising ceremony held on Monday;2, every week a class meeting, the meeting;3, every week two exercises, cleaning and hygiene, behavior norms, attendance situation published cloth appraisal, and the issue of the code of conduct;;4, weekly work week.Monthly moral education work:1, at least once a month, the theme of education activities, to patriotism education, behavior norms of education as the focus, combined with major retreat day.2, the monthly class quantization assessment and class teacher assessment, selection of behavior for the standard model class.Moral education in each term:1, at the end of each semester to form three good student, outstanding student cadres, civilized student.2, at least once a semester, parents will be.,Student etiquette conventionA, the school leavers1, dress neatly to wear school card, step posture correct, full of spirit; cycling of the same students, at the school gat