基于表面活性剂的斜板洗涤器脱除憎水颗粒研究.pdfVIP

中国环境科学 2012.32(2): 226-231 Chína Envíronmental Scíence 基于表面活性剂的斜板洗涤器脱除憎水颗粒研究 舒 心 12，李彩亭 l 气郭忠堂3，张 巍 12，赵亚培 l2，文青波 1 ，2 (1 湖南大学环境科学与工程学院，湖南长沙 410082; 2湖南大学环境生物与控制教育部重点实验室，湖南长沙 410082; 3. 山东山大华特环保工程有限公司，山 东济南 250000) 摘要z 选取十六统基三甲基澳化镀(CTAB)、十二炕基苯磺酸锅。DBS)、月桂醇聚氧乙烯(9)隧(AEC叫和f基盼聚氧乙烯隧(OP-10)配 制成 4 种单一表面活性剂洗涤液，采用新型斜板洗涤器对憎水性炭粉进行湿法除尘实验，探讨表面活性剂种类、入口含尘浓度、空塔气速 和液气比(IJG白)等参数对除尘效率(叩份)和压降(仙M内)的影响 能良好;烈4 种表面活性剂均自能E较大程度提高除尘效率，其中AEO-9 的脱除效果最佳佳;当A础EO-9浓度为0ω07mmo且，入口含尘浓度为 5g/阴m)江丛卢/巧 G 为1.β况0侃LI旷m旷3，空培气速为 2.5m1s 时，除尘效率高达 99.99阳%吮;入口含尘浓度对 M的影响较小，L巧IG 和空培气速对M影响较明显;实验范围内出 口含湿量小于 llglkg(干). 关键词z 僧水颗粒:斜板洗涤器:表面活性J1IJ ，除尘效率;压降 中图分类号: X51 文献标识码:A 文章编号: 1000-6923(2012)02-0226-06 1 Removal of hydrophobic particles with bevel edge scrubber based 00 surfactaots. SHU Xín.2 , LI Caí-tíng ,2., GUO 12 Zhong-tan矿， ZHANG Weí . , ZHAO Ya-peí.2 , WEN Qíng-bo气I.College of Envíronmental Scíence and Engíneeríng, Hunan Uníversity, Changsha 410082 , China; 2.Key Laboratory of Environmental Biology and Pollution Control ,Ministry of Education, Hunan University, Changsha 410082 , China; 3.Shangdong Sd-wit Corporation, Limited , Jinan 250000 , China). China Environmental Science, 2012 ,32(2): 226-231 Abstract: Four surfactants CTAB , SDBS, AEO-9 and OP-l 0 were used for washing liquids preparation respectively. The removal of hydrophobic powdered carbon was carried out with a bevel edge scrubber. The effects of surf画ctants， inlet dust concentration, superficial gas velocity, and liquíd-gas ratio on dust removal efficíency (份皿d pressure drop (11P) were discussed. Furthermore, the dewatering performance of the bevel edge scrubber was evaluated. The bevel edge scrubber had h