动力转向系统常见故障及解决措施(国外英文资料).docVIP

动力转向系统常见故障及解决措施 Common troubles and solving measures of power steering system The common troubles in power steering system are heavy steering, single side heavy, abnormal noise, noise, oil leakage, steering wheel shake / beater, poor stability, poor steering wheel return ability and so on. 1, turning heavy 1) cause of failure: (1) an internal filter is dirty, blocked or an oil level low. (2) there is a lot of air in the power steering system. (3) the steering system has a foreign body, causing the steering pump flow control valve stuck. (4) tire pressure is not enough, the pumps steering column interference, loose connection, the pump belt loose, slippery or pump installation position is loose. (5) the bolt of each joint of the oil pipe is loose, which results in the leakage of the steering fluid. (6) the piston cylinder of the steering gear is worn too much, the seal of the oil seal is not good, and the control valve is stuck or damaged. 2) troubleshooting and troubleshooting: (1) check the steering gear, steering pump control valve, oil filter, steering oil, cleaning the power steering system. (2) if the pump must be clean and dirty, booster pump and tubing (not cotton cloth or other fiber cloth, brush with clean clean), and to the steering system of air discharge according to the provisions. (3) inflate the tires according to the regulations and adjust the engine performance. (4) the provisions of the fuel to the oil level, check or replace the oil cup. (5) adjust the tension of the belt according to the regulations and fasten the connecting screws of each component. (6) check the connecting parts of the tubing and fasten the connecting bolts. (7) replace oil pipe, power steering pump or power steering gear. 2, in the direction of unilateral steering heavy 1) cause of failure: (1) the oil seal of the steering gear is poor, and the connection bolt of the oil pipe is loose, which results in the leakage of the steering fluid. (2) the control valve of the steering g