电 阻 应 变 式 称 重 传 感 器（Electric resistance should be called retransmission sensor）.docVIP

电 阻 应 变 式 称 重 传 感 器（Electric resistance should be called retransmission sensor） Electric resistance should be called retransmission sensor 1. Principle of resistance strain weighing sensor, etc 2. Common technical parameters of weighing sensor 3. General rules for weighing sensors 4. Use the weighing sensor to notice matters 1. Electrical resistance should be used as the original principle of retransmission sensor, Resistance strain type weighing sensor is based on the principle that elastomer (elastic element, sensitive beam) elastic deformation under the action of external force, the resistance strain gauge on the surface of the paste in his (cell) also along with the deformation and deformation resistance strain gauge, its value will change (increase/decrease), and then through the corresponding measurement circuit convert the resistance to electrical signals (voltage or current), so as to complete the process of external force transform into electrical signals. It can be seen that the resistance strain plate, elastomer and detection circuit are the indispensable parts of the resistance strain weighing sensor. The following is a brief discussion of the three aspects. 1. Resistance strain film! The resistance strain gauge is a sheet of resistance wire that is distributed on a substrate made of an organic material. One of his important parameters is the sensitivity coefficient K. Lets talk about what it means. There is a wire resistance wire, whose length is L, and the cross section is a circle with radius r, whose area is called S, whose resistivity is recorded as rho, and the poisson coefficient of this material is mu. When the resistance wire is not acted upon, its resistance value is R:). R = rho L/S (Ω) When his two ends are used by the force of F, it will stretch, which is to say deformation. Set its elongation Δ L, its cross-sectional area is narrow, namely reduce Δ it cross section of the round radius r. In addition, still can use experiments show that the