质感艺术漆施工流程中英文.pdfVIP

质感艺术漆施工流程 Texture art paint construction flow 质感艺术漆施工工序 Texture art paint construction procedure 1．基面处理 base level disposal 2 ．涂封闭底漆 smear sealed base coat 3 ．勾缝 draw sew 4 ．批质感漆 slap tacetile sensation lacquer 5 ．制作花纹 make decorative design 6 ． 除去胶布 remove adhesive plaster 7 ．涂防水面漆 spray waterprooof surface lacquer 一、基面处理 basic level disposal 1．基面的要求 requirement of basic level ⑴对于刚建成的新墙，需要充分养护，干燥；对于已受潮剥离的旧墙，则需重新做底层批荡。 new wall need to be maintenance and desiccation ;old wall affected by damp and peeled off need to be re-make bottom finish ⑵基面应平整、洁净，不得有油污，浮灰或其它污染物。 Basic level should be smooth ,clean ,no oil and floating ash or other contamination ⑶对旧墙体或其它基面上原有的旧涂料，应经试验确认其附著性；若附著性差，则必须彻底 铲除。 Old dope in the old wall or other basic level should be confirmed its attached function .if the function is bad ,must be remove it throughly (4)确认基面强度、平整度、酸碱性、含水率是否达到规定标准。 Confirm the intensity , smooth level, acidity and alkalescence , containing water or moisture of basic level whether reach to the rule standard or not 2 ．验收基面的方法及标准 inspect and then accept the standard and means of basic level 1）墙面平整度及垂直度：用 2M 长的水平尺靠墙面，凹凸不超过±2mm； metope smooth level and uprightness degree :concave and protruding size = ±2mm by the 2M plane ruler alongside the metope 2）阴阳角方正度：用直角尺检验，误差不超过±2mm Yin-yang angle decussation degree: check it by square, error is in ±2mm 3）基面的含水率：含水率 10%以下，PH值 10 以下晴天时利用透明胶布平铺基面，以胶带 containing water or moisture of basic level : down 10% containing water or moisture and PH 10, tile basic level by transparent rubberized fabric or adhesive tape. in sunny day 4) 封合胶布四周，经 2-4 小时后，若胶布内部呈结露现象，则基面含水率高，不宜施工。 Seal rubberized fabric ;after 2-4hours ,if the inside rubberized fabric take on phenomenon of dropping dew ,the results is that containing water or moisture rate of basic level is high ,not fit for working ! 5)用目测或用仪器检测，确认基面强度、平整度、酸碱性、含水率是否达到规定标准。 Confirm the intensity , smooth level, ac