变频器常见问题（Frequency converter common problems）.docVIP

变频器常见问题（Frequency converter common problems） The increase of the transformer capacitance: the principle of easy analysis, but in fact due to the structure and materials of the transformer itself, is unlikely to make any insulation or insulation transformer for high rank, so to increase the transformer greatly is very difficult to ground capacitance C. Two, the causes of over-current and treatment methods 2.1 causes of over current generation (1) over current during operation That is, the drag system appears over current during operation. The reasons come from the following aspects: The motor meets the impact load, or the transmission mechanism appears stuck phenomenon, which causes the sudden increase of motor current. The output side of the inverter circuit of inverter output , as to the connection line between motor has a short circuit, or motor internal short-circuit etc.. The inverter inverters work is not normal, such as two pieces of the same bridge arm inverter inverter in the working process of alternating abnormal. For example, the ambient temperature is too high, or cause the inverter device aging itself, the change of the parameters of the inverter device, resulting in the alternate process, a device is switched on, and another device but has not yet had time off, causing the same bridge arm of the two devices through the DC voltage in a short-circuit state between positive and negative. (2) excessive current during rising speed; When the load inertia, and speed up time is set too short, means that in the process of speed up the work efficiency of the inverter inverter, rise too fast, synchronous speed motor increased rapidly, while the motor rotor speed due to load inertia and to keep up, the result is speed up the current is too large. (3) the over current in the falling speed When the load is greater inertia, and the deceleration time is set too short, it will cause excessive current. Because the deceleration time is too short, the synchronous speed