龙口凤凰山废弃物处理厂斯瓦特台风渗漏液蒸发-曝氧系统方案L.DOC

龙口市凤凰山废弃物处理厂 斯瓦特“台风”系统ongkou City Fenghuang Mountain Waste Management Plant Proposal of SWAT Typhoon Leachate “Evaporation-Aeration” System 美国新概念环保集团山东省渠道供应商 济南裕恒环保设备有限公司 霍 宝 电话(Tel)：（86）0531 手机(MP)一、项目背景 Background of Project 龙口市凤凰山废弃物处理厂所管理的垃圾每天渗沥出来的渗沥液达100吨。由于传统方法处理渗漏液存在着占地面积大，费用高，难度大，处理不彻底的缺点。美国新概念环保集开发的斯瓦特台风”系统Longkou City Fenghuang Mountain Waste Management Plant is facing treating 100 ton leachate per day generated by the garbage. The traditional technology has some shortages of high cost, big land needed, unsatisfied treatment effectiveness. The SWAT Typhoon Leachate “Evaporation-Aeration” System developed by New Waste Concepts Inc is a perfect solution to solve the difficult problem. 二、 技术原理 Principle 斯瓦特“台风”“蒸发-曝氧”系统，是一个低能耗，低维护，和安全的处理废水的一个全新概念，它使用涡轮增压离心雾化喷头（或称旋转雾头）来蒸发废液，每个旋转雾头蒸发量可达每小时1立方米。根据风速，气温和大气压条件，它的效率可达 80-100%，这是传统的废水处理方法和喷嘴喷雾系统所无法与之相比拟的。(下图) SWAT Typhoon ‘Evaporation-Aeration-Recirculation’ System is a completely new concept for evaporating waste water and waste water with an operationally low cost, low maintenance, and safety system. Depending on the technologies of Turbo Centrifugal Atomizing Hub and Basket, each head can consume 1 ton waste water per hour with evaporation efficiency of 80-100% being associated to wind speed and temperature. It is impossible for any conventional waste water treatment methods and nozzle system to reach the goal. 此系统的两个关键技术：Two support technologies in the system 1 涡轮增压离心雾化喷头：采用两级雾化的的技术， 废液首先被输入位于轴心部的涡轮增压器，高速旋转使液体产生巨大的压力，并以雾状喷离涡轮增压器；这些雾粒，继而与具有更大转距线速的筛网壁撞击，从而产生第二次雾化的效果，使雾化的颗粒更细，最后雾粒的大小取决于筛网的孔径。由于巨大的离心力作用和无数筛眼可供液体通过，改变了传统高压喷嘴“千军万马过独木桥”而极易堵塞和对喷液纯度要求极高的致命弱点。其次，因雾化动力是旋转，所以取缔了高压泵系统，使机器工作更加稳定。这是喷雾原理的一种全新改革。 SWAT Turbo Centrifugal Atomizing Hub and Basket: A quad feed two step rotary atomization process is applied. The fluid fed into a rotating hub is ejected by centrifugal force through large holes where it impacts a fine screen mesh rotating at high RPM to further atomize the fluid and cre