大众汽车各类螺丝力矩标准（Volkswagen all kinds of screw torque standard）.docVIP

大众汽车各类螺丝力矩标准（Volkswagen all kinds of screw torque standard） Sometimes the car is being repaired bad, the reason is the most direct cause of damage to the vehicle is in maintenance, the operator did not come to an important bolt car in strict accordance with the technical parameters, these bolts are standard torque respectively, too tight or loose may cause the vehicle to reduce vehicle life, not good, resonance, noise, and traffic accidents. The FAW Volkswagen internal technical data as an example, look at the standard moment. The engine assembly base part: Bora, golf car full of important parameters of bolt torque With the support of bolt (13MM) ----25Nm With the support of bolt (18MM) ----40Nm+90 /50Nm Bearing and engine mount bolt (18Mm) ----100Nm The gearbox and bearing assembly With the support of bolt (13MM) ----25Nm With the support of bolt (18MM) ----40Nm+90 /50Nm Bearing and transmission support bolt (18MM) ----100Nm Swing bracket The swinging rack and gear box bolt ----40Nm+90 /50Nm The swing bracket and the auxiliary frame bolt ----20Nm+90 /25Nm Engine parts Put the oil bolt ----30Nm Oil filter ----20Nm Camshaft timing gear bolt ----90Nm+90 The camshaft wheel bolts ----65Nm Crankshaft bearing ----65Nm+90 The connecting rod bearing ----80Nm+90 The first step of ----40Nm cylinder head bolt The second step ----90 of cylinder head bolt The third step ----90 of cylinder head bolt Knock sensor ----20Nm Double temperature switch ----15Nm Oxygen sensor ----50Nm Three catalytic converter and an exhaust pipe connecting bolt ----40Nm Double exhaust pipe clamp ----40Nm Gearbox parts The gearbox is connected with the engine parts ----80Nm The gear box and start connecting part ----80Nm The gear box and the oil pan screw ----40Nm The shift lever and shell body ----25Nm The shift to the transmission bracket zipper connecting bolt ----25Nm Gearbox oil plug ----25Nm The speedometer drive shaft ----30Nm Transmission cover bolt ----10Nm The clutch master pump ----25Nm Clutc