偏心搅拌反应器内的液相混合行为.pdfVIP

Vo l. 61 No.10 第 61 卷第10 期 化工学报 CIESC Journal October 2010 2010 年 10 月 偏心搅拌反应器内的液相混合行为 E豆豆? 胡银玉，刘苗，杨基础，程易 (清华大学化学工程系，北京 100084) 摘要2 利用先进的无干扰流场测试手段一一胡平面激光诱导荧光技术 (PLI凹，对斜叶桨搅拌反应器内的液相?撮合 过程进行高精皮定量可视化。对比了中心搅拌和 3 种不问偏心里挥下的偏心搅拌混合行为，引人参数混合均匀度 和均匀混合时间定最描述测量平丽的示踪剂浓度分布。研究发现，偏心搅拌过程由于破坏了流场的对称性，比 中心搅拌能更快达到均匀混合。反应器内局部混合存在差异，偏心搅拌中不同监测点达到均匀混合时间差异较 小，体现了偏心搅拌在液相混合中的优势。 关键询:偏心搅拌反应器;ljZ-副激光诱导荧光;液相谁合; t昆合时间;棍合均匀度 中固分类号: TQ 027. 3+ 5 文献标识码:A 文章编号: 0438 一1157 (2010) 10…2517一06 Liquid mixing in eccentric stirred tank HU Yinyo , LlU Zhe , YANG Jicho , CHENG Yi (Department 01 Chemícal Engineering , Tsinghua UnÍl.用rsity ， Beijing 100084 , China) Abstract: The liquid mixing in a pitched blade stirred tank was studied by the non-intrusive planar laser induced fluorescence technique. The mixing behavior in the centric and eccentric stirring operations was evaluated with the parameters such as the uníformity index and the 95 % mixing time calculated based on the measured tracer concentration distribution. The results show that the eccentríc operatíon exhíbits better mixíng performance than the centric operation , owing to its asymmetrical f1 ow. The míxing time is a local variable , depending on the monitoring point , but the variation in the mixing time is small ín the eccentric stirred tank. Key words: eccentric stírred tank; planar laser índuced fluorescence; liquid mixing; mixing time; mixing uniformity 缸，且会使能税增加[叫。为此，研究者提出采取 引言