220th水冷方形分离器循环流化床锅炉的设计及运行（Design and operation of 220th water-cooled square separator circulating fluidized bed boiler）.docVIP

220th水冷方形分离器循环流化床锅炉的设计及运行（Design and operation of 220th water-cooled square separator circulating fluidized bed boiler） Design and operation of 220t/h water-cooled square separator circulating fluidized bed boiler Abstract: Based on 75t/h 130t/ and dozens of successful operation of the circulating fluidized bed, circulating fluidized bed boiler is developed using 220t/h water-cooled square separator, by the end of 2001 in Shandong Weihai power plant put into commercial operation. This is one of the largest circulating fluidized bed boilers with Chinese technology. The operation of the furnace is introduced in this paper. Because of the characteristics of the water-cooled square separator and the full film wall structure, the boiler starts quickly and the ash temperature drops slightly, and so on. The particle size distribution and combustion of fly ash, circulating ash and slag is similar to coal equivalent diameter round cyclone of CFB boiler is very similar. The combustion efficiency is ideal, and the pollutant discharge meets the national standard requirements. Its fuel adaptability, load change rate, especially reliability is very superior. Key words: 220t/h boiler; water cooled square separator; circulating fluidized bed; test run 1 Introduction Chinas energy structure, coal occupies an absolute advantage, clean coal combustion technology has been highly valued. Since the beginning of 1980s, the research and development of circulating fluidized bed combustion technology has been carried out, and a batch of cheap circulating fluidized bed boilers with Chinese characteristics at 75t/h and below capacity levels have been developed. The completion of the national 75t/h circular fluidized bed boiler demonstration project supported by the State Economic and Trade Commission in 1990s marked the full commercialization of the CFB boiler with the capacity grade [1,2]. Subsequently, a batch of medium or high pressure circulating fluidized bed boilers with 130t/h capacity