工业润滑油使用中常见问题（Common problems in the use of industrial lubricants）.doc

工业润滑油使用中常见问题（Common problems in the use of industrial lubricants） What is the reason 1, pollution caused by hydraulic oil particles? What is the harm? What are the way to prevent? (1) reason There are two reasons for the pollution caused by hydraulic oil particles: The first is the foreign into, two is in the course of work. See the following table Foreign production 1, after the air tank breathing hole dust into the 1, by moving parts wear of the metal powder particles. 2, transportation, storage and transportation process of mixed 2, hydraulic oil produces chemical changes of the sludge, precipitation etc. There are 3 components of the hydraulic system in 3, seal, gasket and hydraulic oil can not adapt to the resulting (2) harm A bond, blocking filter, servo valve hole Wear B pressure pump and motor components C accelerated the aging of oil deterioration D blocked suction strainer, the pump cavitation (3) to prevent A tank sealed, dust, or install a breathing hole with air filter B oil storage process must be dustproof, waterproof Equipped with a filtering device to remove pollution particles must be in the C system, the best use of filter signal indicating, at the bottom of the tank to install the best magnetic trap. D installation and regular inspection, cleaning pump suction strainer. E in the cylinder and the push rod seals and shields, or blowing dust. 2, the same mineral hydraulic oil viscosity can be used each other? Not. Because has the same viscosity, but the type of far. Requirements for high voltage system of antiwear hydraulic oil, can not use L-HH or L-HL instead of oil or it will cause the equipment to pump scrapped prematurely and operation failure, in L-HV and L-HS oil hydraulic system in cold region requires the use of nor with the same grade L-HM oil to substitute, otherwise may cause difficult cold start etc.. Two, gear oil problems and Solutions 1, what is the main form of gear failure? The main form of gear failure has broken teeth, wear, pitt