丝网印刷的术语（Terminology for screen printing）.docVIP

丝网印刷的术语（Terminology for screen printing） The screen of the term 1. screen. The screen is used as a fabric screen support body. I tulle, silk screen, screen, screen etc.. 2. screen mesh. The screen mesh is per square centimeter (cm2) the number of screen mesh. Product specifications for wire mesh unit expression is hole / cm / cm or line. Using imperial units of countries and regions, with holes per inch or lines per inch to express the screen mesh. Between the wire and mesh can be silk screen of the dense degree. The number of Kose network more dense, smaller mesh. On the other hand, the lower screen mesh is sparse, the mesh is larger, such as 150 mesh / inch, which has 150 wires within 1 inches. The mesh is small, the ink through the mesh, the greater the ink through the better. In the selection of screen printing according to the requirements of the accuracy of different mesh size of the screen. 3. screen thickness. The screen thickness between the mesh surface and the bottom surface of the distance in mm (mm) or micron (m) measurement. The thickness should be measured at the screen without tension in static state value. The thickness is determined by the diameter of a wire mesh screen composition, quantity and thickness of ink. The opening of the 4. screen. The opening of the screen is an important parameter to describe the screen hole width, diameter, mesh size. The opening degree for the fine screen printing products pattern and character influence. The opening degree of the actual representation of the mesh width, with square root network latitude two line formed to represent the mesh size (usually in microns and 1 microns =1/1000 mm). Therefore, the mesh side length is longer opening more. However, the opening degree of the same, because of woven materials and operating method of screen printing effect is different, there are good and bad. The opening of the following formula: O=A1/2 (AB) 1/2 Type: O - opening (m); A mesh size; A, B - on both sides of the adj