正确使用聚丙烯酰胺干粉的方法（Proper use of polyacrylamide dry powder）.docVIP

正确使用聚丙烯酰胺干粉的方法（Proper use of polyacrylamide dry powder） Dissolve a and PAM: PAM powder added to the water, will immediately produce bentonite, if an amount too much to agglomerate, forming the so-called longan, fish, not only difficult to dissolve, and often cause blockage of the dosing pump; secondly, too fine PAM powder, investment the dissolving tank because of light, easily flying through the air, causing environmental pollution. The correct method is usually dissolved, stirring in the case of a small amount of water added to the continuous quantitative methods, side spraying side and dissolved, it can effectively prevent fish eye shape is not dissolved, and effectively shorten the solution time. Two, dissolved mixing conditions: dissolved tank to cylinder type is better, and the liquid level of the cylinder height of 1.2 to 1.5 times the diameter of the ideal liquid level. The four corners of square tube because of turbulence effect, easy dead angle, in order to avoid the stagnation of undissolved particles accumulation of dead, should be avoided. The mixer can be vertical or horizontal. Three, PAM dissolved concentration: powder PAM generally use the content of 0.05 - 10% of the aqueous solution, the specific concentration must be based on the specific characteristics of the sludge. Four note: as mentioned earlier, PAM is almost free of toxicity, and some of the hydrolysates may be irritating. In the process of operation, the inhalation of PAM powder and the solution should be adhered to the eyes and nose. Once it happens, the water should be washed again and again with plenty of water. When dissolving operations, it is best to wear goggles, rubber gloves and other protective equipment. Where the solution is splashed around the site, it will be dangerous to rinse and keep dry as it is sticky and slippery. PAM powder products if unopened, exposed to the air for more than a year, the quality will not change, but because the product has a strong moisture absorpti