带亲水层条缝型翅片管换热器析湿工况空气侧换热及压降特性.pdfVIP

第21 卷第4 期 高 校 化 学 工 程 学 报 No.4 Vol.21 2007 年 8 月 Journal of Chemical Engineering of Chinese Universities Aug. 2007 文章编号：1003-9015(2007)04-0575-06 带亲水层条缝型翅片管换热器析湿工况空气侧换热与压降特性1 马小魁, 丁国良, 张圆明 (上海交通大学 制冷与低温工程研究所, 上海 200030) 摘 要：对带亲水层条缝型翅片管换热器在析湿工况下的空气侧特性进行了实验研究。分析了翅片间距、管排数和入 口相对湿度对空气侧换热及压降特性的影响。研究结果表明，当雷诺数较低时，翅片间距对空气侧换热特性的影响很 小，当雷诺数大于 1600 时，空气侧换热特性随着翅片间距的增大而逐渐减小。翅片间距对空气侧压降特性的影响则同 干工况相似。管排数对空气侧换热特性的影响非常明显，但对空气侧压降特性的影响则不明显。空气侧的换热性能随 着入口空气相对湿度的增大稍微有所增强，而压降特性则几乎不受入口相对湿度的影响。开发了析湿工况下带亲水层 条缝型翅片管换热器空气侧换热因子 j 和摩擦因子f 的关联式。平均误差分别为 9.6%和 7.8%，在±15%误差范围内分 别能涵盖 82.1%和 89.3%实验数据。 关键词：条缝翅片；析湿工况；亲水层；换热；压降 中图分类号：TK172 ；TK124 ； TQ021.3 文献标识码：A Airside Heat Transfer and Pressure Drop Characteristics of Slit Fin-and-Tube Heat Exchangers under Dehumidifying Conditions MA Xiao-kui, DING Guo-liang, ZHANG Yuan-ming (Institute of Refrigeration and Cryogenics, Shanghai Jiaotong University, Shanghai 200030, China) Abstract: The airside heat transfer and pressure drop characteristics of slit fin-and-tube heat exchangers with hydrophilic coating were studied experimentally under dehumidifying conditions. The effects of fin pitch, number of tube rows and inlet relative humidity on airside performance were investigated. The results indicate that the effect of fin pitch on the heat transfer is small when the Reynolds number is low, while the heat transfer decreases with increase of fin pitch if the Reynolds number is bigger than 1600. The effect of fin pitch on the pressure drop is similar to that for dry conditions. The effect o