Study on Hydrogen Permeation in DP and QP Grades of AHSS underCathodic Charging and Simulated Service论文.pdfVIP

Study on Hydrogen Permeation in DP and QP Grades of AHSS underCathodic Charging and Simulated Service … ·1 · Study on Hydrogen Permeation in DP and QP Grades of AHSS under Cathodic Charging and Simulated Service Conditions 1 1 1 1 2 1 Liu Qinglong , Venezuela Jeffrey , Zhang Mingxing , Zhou Qingjun , Atrens Andrej (1. The University of Queensland, Division of Materials, School of Mining and Mechanical Engineering, St. Lucia, 4072 Australia； 2. Baoshan Iron Steel Co., Ltd., Research Institute, Shanghai 201900, China) Abstract The hydrogen permeation behaviour of DP and QP grades of advanced high strength steels was investigated using the permeability experiments (1) under cathodic charging at different potentials in 0.1 M NaOH solution, (2) in 3% NaCl solution at the free potential simulating the corrosion behaviour of non-galvanized steel in service and (3) at zinc potential for the corrosion condition of the galvanized steel during actual service.Under cathodic charging at different potentials in 0.1 M NaOH solution, hydrogen permeation decreased with less negative charging potential, reflected by lower values of permeation rate and diffusion coefficient. At the most severe charging condition of –1.700 VHg/HgO in the 0.1 M NaOH solution, the permeation rate for 1200 DP-GI steel was 1.53 µA/cm and for 980 QP steel was 0.492 µA/cm. The values for 1200 DP-GI and 980 QP steels at the least severe charging condition of –1.100 VHg/HgO were 0.178 µA/cm and 0.111 µA/cm, respectively. The hydrogen permeation rate under simulated servic