测试报告E45019 St.-Cleaner 2012.02.16 Pre.-Prod.docVIP

Technical Evaluation Report Sample status: Product Name: Steam cleaner Photo of whole unit E- No.: E45019 Customer + Country IB- USA Supplier Cixi v-mart Model No.: GT-DR-01-US Sample QTY: 1 Merchandiser Ger. Heike Reimers Merchandiser Asia QS Handling Hamburg Isabelle Zimmer Plug: Power cord: Rating: length 247cm without plug 100-120V; 60Hz; 900-1050W Merchandiser approval: OK Not OK Conditional Released Merchandiser Remarks: Retest required ____________________________________________________________________________ The results are exclusively based on the presented sample! Evaluation Result of technical department: OK Not OK Conditional Released Summary of essential improvements: Improvment of mentioned points under workmanship Thighter and safer locking of the accessories -- too loose when unit in use Steam temperature at nozzle outlet must be at least as high as last model Previous reports: Steam Cleaner UK E44034 with UK plug.doc; Steam Cleaner UK E44034 2011.03.07.doc; Steam Cleaner E42183 2010.05.25.doc EV-Special Test (for all Units) Improvement to previous Test A12 Special Temperature Endurance Test Max. loading Test Comparison Test 1 vs.2 Cross-cut adhesions test Consult Merchandiser at first sight of major damage or lack of use at the tested unit to save unnecessary EV-Report! EV- Level 1 (for all Units which have to be send out immediately) No EV-Report. Short basic function test Marking obvious defects EV-Level 2 (only mass production units; small countries e.g. F, UK etc) Required time 2-4 hours With EV-Report Short function test according to IM EV-Level 3 (only for units in the pre-production stage; small countries e.g. F, UK etc.) Required time 3-5 hours With EV-Report Short function test according to IM All possible changes and failures should be noted Plausibility check of the manual Endurance test (optional) Critical test (e.g. max. load for hand m