玉环电厂4×1000MW超超临界工程2、4号机组热力系统的化学清洗研究.pdfVIP

2008.10 中国 南京 清洁高效燃煤发电技术协作网 2008 年会 1 玉环电厂 （4 ×1000MW）超超临界工程 2 、4 号机组热力系统的化学清洗 滕维忠，鲁礼勋 西安热工研究院有限公司，陕西西安 710032 Chemical Cleaning of Ultra Supercritical Unit Thermal System of No.24 Units in YuHuan Power Plant (4×1000MW) TENG Wei-zhong, LU Li-xun Xi’an Thermal Power Research Institute Co Ltd ShanXi XiAn 710032 摘 要：华能玉 1000MW 超超临界电厂 2 、4 号机组热力系统化学清洗的范围包括过热器、低压过热器的水冲洗，凝 汽器、高压加热器汽侧、高低压加热器、高低压给水系统、除氧器、炉本体的碱洗和高压加热器、高低压给水系统、炉 本体的 EDTA 氨盐除锈清洗。清洗动力使用了凝结水泵、炉水循 泵和给水泵前置泵。清洗过程严格按预定措施执行， 取得了优良的清洗效果，满足了机组热力系统净化和整套试运对水汽品质的要求。 关键词：超超临界；热力系统；化学清洗 ABSTRACT: The chemical cleaning Scope of thermal system of 1000MW ultra supercritical 24 units in YuHuan Power Plant included water flushing of super heater and the steam side of low pressure heater, alkaline cleaning of steam side of condenser and high pressure heater, alkaline cleaning of feed water system (including high pressure heater, lower pressure heater, oxygen deaerator and boiler proper), EDTA-NH4 rust remover cleaning of boiler proper and feed water system. The cleaning driving force used the condenser pump, boiler start-up circulating pump and pre feed pump. The cleaning processes were done strictly according to the measure and has a good cleaning result which satisfied the requirements of thermal system purge and watersteam quality of unit full set commissioning. Key words: Ultra Supercritical, Thermal System, Chemical Cleaning 出口温度： 603 ℃ 0 热力系统简介 省煤器进口给水温度：298 ℃ 0.1 锅炉参数 0.1.