正交试验法优选控制初滤水浊度最佳工艺.pdfVIP

1 1 2 2 郜玉楠 李伟光 黄晓东 张金松 ( 1 , 150090; 2 ( ) , 51803 1) 降低初滤水浊度是提高出水水质的关键, 以深圳水库水作为原水进行初滤水浊度控制的 研究通过正 试验方法, 比较了四种影响初滤水浊度的因素中试结果表明: 降低沉后水浊度和 采用二次微絮凝对改善初滤水浊度起主要作用, 调节流速与向反冲洗残留水投药的影响较小, 并提 出了以二次微絮凝和调节过滤初期流速为控制初滤水浊度的组合工艺, 采用聚氯化铝作为微絮凝 剂, 投加量0. 2 mg/ L, 调节初滤水流速从3 m/ h 到8 m/ h, 时间间隔10 min 正 试验 初滤水 浊度 工艺参数 Application of the orthogonal test method on optimal control of turbi dity in initial f ilter effluent 1 1 2 2 Gao Yunan , Li Weiguang , H uang Xiaodong , Zhang insong (1. School of M unicip al and Environmental Engineering , H arbin I nstitute of Technology , H arbin 15 9 , China; 2 . Shenz hen Water Group Co. , L td. , S henz hen518 31 , China) Abstract: Decreasing the turbidity of initial f ilter effluent is pivotal for increasing the effluent w ater quality. This research investigated the tur bidity co ntrol of initial filter effluent w ith the raw w ater from Shenzhen r eserv oirs. Four factors that influenced the turbidity of effluent had been com pared by the m ethod of orthog onal test. Results show ed that : decrease of the turbidity of sediment water and application of secondary microOflocculation play ed a signif icant r ole in improving the tur bidity of initial filter effluent ; adjusting the velocity of flow and adding purif ication chem icals to backw ash remnant w ater brought slight influence. Furtherm ore, this search proposed a co mbined process, consisting of secondary microOflo cculation and adjustm ent of the initial v elo city of flow , for the control of the initial f ilter effluent . Poly Aluminium chloride w as used as