超高性能混凝土配合比设计研究.pdfVIP

学兔兔 2015年 第 1期(总第 303期 1 混 凝 土 理 论 研 究 Number 1 in 2015(Total No．303) Concrete THEORETICAL RESEARCH doi：10．3969~．issn．1002-3550．2015．01．018 超高性能混凝土的配合比设计研究 徐立斌。董 艺。陈尚伟 (贵州中建建筑科研设计院有限公司，贵州贵阳550006) 摘 要：超高性能混凝土(含5 mill以上粗骨料)由于其抗压强度高、耐久性强等优异特点，是一种节材、节地、节能的新型建筑 材料，是国内、外混凝土技术的发展趋势。但由于其胶凝材料用量较大，水胶比较低，拌合物黏稠导致其泵送能力较差，易发生堵 泵、爆管等事故，阻碍其在工程中的大量应用。通过合理的配合比设计、配制和生产了含有粗骨料100 MPa以上、可超高泵送的 超高性能混凝土。通过采用矿渣粉、粉煤灰、硅粉等矿物掺合料复配设计，优化配合比的相关参数，得出配制100 IVIPa以上的超 高强混凝土时，应适量增加矿物掺合料的掺量，提出提高水灰比，降低水胶比的设计方法更合理。 关键词：超高性能混凝土；矿物掺合料；配合比设计 中图分类号：TU528．062 文献标志码：A 文章编号：1002—3550(2015)01—0072—03 Research on the mixture ratio design of ultra—high performance concrete XULibin，DONG Yi，CI-~N Shangwei (Guizhou Science Research and Design Institute of CSCES，Guiyang 550006，China) Abstract：Ultra—high performance concrete(including the coarse aggregate of over 5mm)，with high compressive strength and strong durability，is regarded as a new—type building material that could economize on raw materials，land and energy and the development trend of concretetechnology both at home and abroad．However，thelarge consumption ofbindingmaterials，lowwater—binder ratio and the viscous mixture are prone tO give rise to the inferior pumping capacity，pipe blockage and pipe break，thus preventing its massive ap— plication in the real projects．Therefore，through the design of reasonable mixture ratio，it makes up and produces the pumping ultra— high performance concrete of over 100MPa that contains coarse aggregate by adopting the compound design of mineral admixtures，such as slag powder，fly ash and ganister sand SO aS to optimize the relevant parameter of the mixture ratio．Finally it