吸附作用下真空制冰特性的试验分析-化工学报.PDF

第 65 卷 第 10 期 化 工 学 报 Vol.65 No.10 October 2014 2014 年 10 月 CIESC Journal ·4131 · 吸附作用下真空制冰特性的实验分析 章学来，赵群志，孟祥来，李春蕾，徐斌 (上海海事大学冰蓄冷技术研究所，上海 201306) 摘要：基于水的真空闪蒸理论，设计了一种吸附作用下闪蒸制冰的实验装置。在一定的预设压力值（400 、600、 800 Pa ）、液面高度（20～50 mm ）及初始温度（32、22 ℃）条件下，进行了有无吸附模块的对比性实验。对实 验结果进行了定性分析，结果表明：与无吸附条件相比，在吸附作用下，闪蒸室压力及液体温度下降得更快，沸 石吸附模块的存在能够强化真空条件下水的闪蒸。同时分析了液面高度对闪蒸的影响，相同的初始温度、预设压 力条件下，液面高度越小，吸附条件下闪蒸室的压力下降得越快。 关键词：真空；沸石；吸附；制冰；强化 DOI ：10.3969/j.issn.0438-1157.2014.10.050 中图分类号：TK 02 文献标志码：A 文章编号：0438—1157 （2014 ）10—4131—07 Experimental analysis of ice-making characteristics with adsorption in vacuum environment ZHANG Xuelai, ZHAO Qunzhi, MENG Xianglai, LI Chunlei, XU Bin (Institute of Cool Thermal Storage Technology, Shanghai Maritime University, Shanghai 201306,China) Abstract: Based on the theory of vacuum flash of water, a flash device is designed for experiment of ice-making under the condition of adsorption. Vacuum preparation of binary ice makes use of the principle of the triple point of water. However, the water flash will inevitably increase the chamber pressure and the pressure will be higher than the triple point (611 Pa). This paper proposes a method using solid adsorbent to maintain the pressure. Based on the initial establishment of a low pressure environment, the flash vapor can be adsorbed by the solid zeolite adsorbent in the closed system. Due to the experimental conditions, only the effect of adsorption modules on the flash is analyzed. At certain preset pre