百万吨年焦化厂焦炉煤气脱硫工段的设计文档.docVIP

百万吨年焦化厂焦炉煤气脱硫工段的设计 本科生毕业设计100万吨年焦化厂焦炉煤气脱硫工段的设计 摘 要本设计为100万ta焦化厂焦炉煤气脱硫工段的设计采用的煤气脱硫方法为湿法脱硫的改良ADA法本设计的主要任务是脱除焦炉煤气中的硫化氢同时要使生产出来的煤气各项指标能满足要求达到民用煤气的标准设计的主要内容包括1煤气脱硫方法的概述和意义2工艺流程的选择与论证选用改良ADA法3主要设备的计算选型和布置4保障生产正常进行所必须的非工艺部分包括供水供电采暖设备维修仪表自动化等5经济核算每生产一吨焦炭该设计工段亏损70元本设计的工艺部分包括煤气脱硫和脱硫液再生以及硫磺回收脱硫采用了脱硫塔再生部分用再生塔对于其基本原理文中有着详细的论述回收硫部分采用了真空过滤机在设计过程中参考了焦化厂的焦炉煤气净化工艺并在其基础上将国内外一些新的成熟的工艺进行了比较引用关键词焦炉煤气脱硫 改良ADA法 AbstractThis is a design of 100 million t a coking plant coke oven gas desulfurization section the method for gas desulfurization is the improved ADA law The main task of this design is the removal of hydrogen sulfide in coke oven gas and the gas produced to make the indicators to meet the requirements to civilian gas standards at the same timeThe main contents of the design are as follows1 an overview of gas desulphurization and significance 2 the process of selection and demonstration select the improved of ADA Act 3 the calculation selection and arrangement of major equipment 4 the security necessary for normal production of non-technology components including water electricity heating equipment maintenance instrumentation and automation5 the economic accounting produce 1 ton of coke necessary to loss of 71442 yuanPart of the design process including gas desulfurization and regeneration of the desulfurization solution and sulfur recovery In zhe deign part of desulfurization the desulfurization tower is used recycled parts recycled tower is used For the basic principles the paper has a detailed discussion Part of sulfur recovery the vacuum filter is usedIn the design process with reference to the coking plant in Xuzhou Universe coke oven gas purification process and on its basis compared the home and abroad new mature technology and referencesKey words coke oven gas desulfurization improved ADA Act目 录1 总论211 焦炉煤气脱硫的目的和意义212 硫化氢的性质213 设计的要求与说明214 设计的任务215 厂址的选择2151 地理条件2152 资源条件2153 供排水条件2154 交通运输条件2155 经济条件2156 气候条件22 脱硫工艺论证及确定221 脱硫方法概述2211 干法脱硫221