中国电动汽车标准现状及发展趋势.ppt

International standard Parameter China proposal US proposal Japan proposal EU proposal Structure PIN 9 7 10 (1 spare) 9 Rated voltage 750V/250A 600V/200A 600V/150A 850V/200A Communication CAN PLC CAN PLC Part 3 DC charge coupler GB/T 20234 Connection set of conductive charging for EV 电动汽车传导式充电连接装置 Typical control pilot circuit for mode 4 Charging mode 4 GB/T 20234 Connection set of conductive charging for EV 电动汽车传导式充电连接装置 1. Overview of Chinese Electric Vehicle Standardization中国电动汽车标准化工作概况 2. Frame for Chinese EV standards 电动汽车标准体系 3. Plan and Road Map 未来工作计划和路线图 Outline报告提纲 Roadmap of standardization REESS Li-ion battery super capacitor nickel-hydrogen battery new type battery（zinc-air, Sodium sulfur battery） Mechanical abuse vibration/fall/shock humid/Seawater immersion ? Compressive deformation Temperature abuse fire thermal shock cycle without heat management Electrical abuse short circuit over charge/discharge high voltage protection malfunction analysis ? classification level code E-moter system specification of all kinds of e-motor（AC, permanent magnetism） specification of e-motor controller specification of power devices performance torque/speed/efficiency power output Temperature rise mechanical strength of structure environmental suitability Commutator test electrical insulation dielectric strength ? voltage/circuit control safety high voltage protection EMC Roadmap of standardization electric control system standards communication protocol specification of complete vehicle controller and energy controller Application of international standards Roadmap of standardization Auxiliary electrical standards Electric air conditioning Electric steering Electric brake and energy recovery system special meters for EV high voltage connector and wireharness Roadmap of standardization Charging system/swap system charging coupler swap coupler charging wire harness protocol on board charger Roadmap of stand