燃煤电厂烟气除尘脱硫工程设计论文.docVIP

广东工业大学环境工程专业毕业论文 450MW燃煤电厂烟气除尘脱硫工程设计PAGE PAGE I设计总说明本设计针对燃煤废气的性质，采用电除尘，选用由湿式石灰石/石膏法改良优化后的双循环湿式石灰石FGD工艺（DLWS）来脱硫。电除尘技术比较成熟，具有除尘效率高，运行稳定，维护量小。湿式石灰石/石膏法改良优化后的双循环湿式石灰石FGD工艺：石灰石的利用率大97％以上，运行可靠，没有备用吸收塔，可以多台锅炉使用一个吸收塔；脱硫率达90％以上，高的可达95％；净化后烟气经冷却塔排出而不进烟囱。是比较好的一种脱硫技术，适合中大型电厂。关键词：二氧化硫 燃煤废气 电除尘 湿式石灰石/石膏法改良优化后的双循环湿式石灰石FGD工艺（DLWS）abstractThe design for the nature of coal-fired emissions, using ESP, selected by the wet limestone / gypsum improved optimization of the two-cycle wet limestone FGD technology (DLWS) to desulfurization. ESP technology more mature, dust with high efficiency, stable operation, maintain a small amount. Wet limestone / gypsum improved optimization of the two-cycle wet limestone FGD technology: the utilization of the limestone over 97%, reliable operation, no backup absorber, you can use a boiler absorber; desulfurization rate of more than 90 percent, high Of up to 95%; purified gas from the cooling tower instead of into the chimney. Is a relatively good desulfurization technology for medium and large power plant. Key words: sulphur dioxide ，emissions, ESP ，coal dust wet limestone / gypsum improved optimization of the two-cycle wet limestone FGD technology (DLWS)目录 TOC \o 1-3 \h \z \u HYPERLINK \l _Toc200207642 设计总说明 PAGEREF _Toc200207642 \h I HYPERLINK \l _Toc200207643 1 绪论 PAGEREF _Toc200207643 \h 1 HYPERLINK \l _Toc200207644 2 烟气除尘脱硫的工艺及技术的介绍 PAGEREF _Toc200207644 \h 3 HYPERLINK \l _Toc200207645 2.1 废气脱硫的工艺方法 PAGEREF _Toc200207645 \h 3 HYPERLINK \l _Toc200207646 2.1.1湿式石灰石/石膏烟气脱硫 PAGEREF _Toc200207646 \h 3 HYPERLINK \l _Toc200207647 2.1.2 旋转喷雾干燥法烟气脱硫 PAGEREF _Toc200207647 \h 3 HYPERLINK \l _Toc200207648 2.1.3 简易湿式石灰石/石膏法烟气脱硫 PAGEREF _Toc200207648 \h 5 HYPERLINK \l _Toc200207649 2.1.4 海水烟气脱硫 PAGEREF _Toc200207649 \h 5 HYPERLINK \l _Toc200207650 2.1.5 电子束法烟气脱硫技术 PAGEREF _Toc200207650 \h 5 HYPERLINK \l _Toc200207651 2.1.6 烟气循环流化床脱硫技术 PAGEREF _Toc200207651 \h 5 HYPERLINK \l _Toc200207652 2.2 废气除尘方法 PAGEREF _Toc20020765