电厂工业废水处理后回用于脱硫工艺水的试验研究.docxVIP

电厂工业废水处理后回用于脱硫工艺水 的试验研究 孙立娇 叶治安 胡特立 李荣轩 曹瑞雪 王宏宾 西安热工研究院有限公司北方联合电力乌海热电厂 摘要： 为提高全厂水资源利用率，河北某电厂对处理后的电厂工业废水水质与脱硫工 艺用水水质要求进行比较，发现二者较为接近;该厂处理后的工业废水量仅占脱 硫工艺用水总量的7%,认为可将其用作脱硫工艺水。为进一步降低风险、制定 合理的工业废水利用方案，进行了现场试验研究。试验结果表明，处理后的电厂 工业废水用作脫硫工艺水后，脱硫系统运行正常;脱硫效率大于或等于95%;脱 硫浆液密度维持在1 130kg/m3左右;脱硫副产品石膏的含水率基本保持在10%左 右，CaC03质量分数小于3%, CaSO4 - 2H20纯度大于90%,符合市场对石膏品质的 要求。据此，河北某电厂处理后的工业废水可回用于该厂脱硫系统。 关键词： 燃煤屯站;工业废水;废水回用;烟气脱硫;工艺水; 作者简介：孙立娇（1987—）,女，吉林延边人，工学硕士，从事火力发电厂水 处理设计与研究。E-mail: sunl j515@163. com 收稿日期：2016-09-27 Feasibility Analysis on Reusing Treated Industrial Wastewater for Desulfurization Process Water in Power Plants SUN Li jiao YE Zhian HU Teli LI Rongxuan CAO Ruixue WANG Hongbin Xi anThermal Power ResearchJ^istitute Co. 、 Ltd.; North United Power Wuhai Thermal Power Plant; Abstract： In order to improve the utilization rate of the entire plant water resources, the quality of treated industrial wastewater in one thermal power plant of Hebei Province is compared with the quality requirements of desulfurization process water, which concludes that they are quite close to each other. Since the amount of the trcatcd industried wastcwatcr accounts for only 7% of the total desulfurization process water, it is decided to use it as desulfurization process water. To further eliminate the risks and make the utilization plan properly, the on-site testing study is carried out. The results show that the desulfurization system runs normally after the treated industrial wastewater is served as the influent water for desulfurization. Meanwhile, this system has a desulfurization efficiency of no less than 95%. The slurry density maintains at 1 130 kg/m during the operation process. The water ratio of the gypsum as the desulfurization byproduct is about 10%, and the weight percentage of CaC03 is less than 3%. The purity of CaS0t ? 21I20 is above 90%, which satisfies the market requirements for the quality of gypsum. Therefore, the treated industrial wastewater is eligible to be reused in desulfurizatio