E+H电磁流量计培训资料全.pptVIP

REFERENCE: please contact SC-CH / Mr. Leardi for further information (Olten Water) Branch: Water Application: The sewage of the Olten region is treated by ARA Olten. The plant went into operation in 19??. The sewage quantity treated 电流ly amounts to ?????. This sewage-treatment plant uses the sewage sludge it generates to produce digester gas before draining and burning the sludge. The gas thus produced covers up to ??% of the energy demand of the plant. At intervals, the digestion tower is charged with the sewage sludge. Depending on the quantity of dry solid matter charged, a corresponding quantity of gas is produced by the digesting process. Once the putrefaction process is completed, the digestion tower is emptied and re-charged. The Measuring TaskThe plant operator wanted to be able to determine the solids content of the sludge when charging the digestion tower to be able to calculate the entire sediment discharge on this basis. This enables him to deduce the degree of efficiency of the gas production. The sludge is conveyed in batches from a 100m3 sludge tank to the digestion tower. This quantity is measured by a Promag 33 F.The SolutionA Promass 83 I with a nominal width of 50 was installed in a by-pass in the connecting pipe from the tank to the digestion tower. This solution was chosen because the entire volume flow is already measured by an MID. Given that, here, the Promass 83 device only has to measure the concentration, a smaller and more cost-efficient measuring device may be used. The Promass I 传感器 is particularly suited for media with a solids content as the danger of clogging or stoppage, even in case of a fibrous content, is quite low due to the straight measuring pipe. Besides, the integrated vibration compensation guarantees a troublefree operation even if it is inserted without special supports The Function Principle of the Concentration MeasurementIn addition to the mass flow, Promass 83 measuring devices record the density and temperatur