018-区域热水锅炉房供热输送干线疲劳寿命研究.pdf

分类编号：01 区域热水锅炉房供热输送干线疲劳寿命研究 郑方，雷勇刚,王飞 （太原理工大学环境科学与工程学院，山西太原030024 ） 摘 要：针对我国区域热水锅炉房供热管网疲劳寿命的研究现状，采用泊尔姆格林-米纳公 式，对供热管网的疲劳寿命进行计算和研究。本文选取太原、石家庄、大同、运城作为代表 性供热城市，通过调查问卷和实际测量方法，对区域热水锅炉房的事故情况及管网热工参数 进行统计。结果表明，四座代表城市区域热水锅炉房输送干线疲劳寿命循环次数区间为分别 为（81.94，99.01 ）、（73.62，86.02）、（93.63，110.01）、（67.56，74.62 ），均值分别为89.04、 79.33、101.81、71.77 ，与城市所在地的供暖室外计算温度值成反比且与供暖时长成正比。 研究结果为今后直埋供热管网的设计规程提供重要的实验参考依据。 关键词：区域热水锅炉房；输送干线；事故频次；疲劳寿命 Study on the fatigue life of heat transfer trunk in hot water boiler room Zheng Fang ，Lei Yonggang ，Wang Fei (School of Environment Science and Engineering, Taiyuan University of Technology, Taiyuan 030024，China) Abstract ：Based on the research status of the fatigue life of heating pipe network in hot water boiler room in China, the fatigue life of the heating pipe network is calculated and studied by using the palmgren-miner formula. This paper selects Taiyuan, Shijiazhuang, Datong and Yuncheng as representative heating cities. Through questionnaires and actual measurement methods, the accident situation of hot water boiler room and the thermal parameters of pipe network were measured. The results showed that the number of cycle times of fatigue life cycle of the four representative urban hot water boiler rooms were respectively (81.94, 99.01), (73.62, 86.02), (93.63, 110.01), and (67.56, 74.62). The mean value is 89.04, 79.33, 101.81 and 71.77 respectively, which is inversely proportional to the calculated temperature of the heating outside the city, and is proportional to the length of the heating. The research results provide important experimental reference for th